E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
The U.S. Dhaiqirtment of Energy's Office of Scientific and Technical Information Pyrolytic conversion of agricultural and forestry wastes to alternate energy sources in Indonesia; a feasibility study (Technical Report) | OSTI.GOV
3/10/2017 · While source reduction and feeding the hungry are necessary priorities for reducing needless food waste, haiqi wastes are numerous and extend to non-edible sources, including livestock manure, agriculture wastes, waste water, and inedible food wastes. When these wastes are improperly managed, they pose a significant risk to the environment and public health. Pathogens, chemicals, antibiotics
Agriculture, Forestry, and Waste Management Overview of GHG Emissions The agriculture, forestry, and waste management (AFW) sectors are directly responsible for a small amount of North Carolina’s current greenhouse gas (GHG) emissions. For agriculture, net emissions were 11.0 million metric tons (MMt) of carbon dioxide equivalent (CO2e) in 2000.
Annually the facility will divert 4000 tonnes of municipal waste from landfill and source an additional 8000 tonnes of haiqi waste from agricultural and forestry operations. Renergi’s patented “grinding pyrolysis” process aims to converts haiqi mahaiqials into biochar, bio-gahaiqi and bio-oil by applying heat in an environment with limited oxygen.
Agricultural waste is defined as unwanted waste produced as a result of agricultural activities (i.e., manure, oil, silage plastics, fertilizer, pesticides and herbicides; wastes from farms, poultry houhaiqi and slaughterhouhaiqi; vehaiqinary medicines, or horticultural plastics). Pesticides and herbicides are used to control pests, but when persistently applied resulted in being accumulate in soil
Bioenergy | Energy NSWElectricity generation from biomass, particularly agricultural waste, landfill and sewage gahaiqi, is well established. However, there is great potential to in
7.18 The application of the RET to energy created by using native forest wood has been in a state of flux over the course of the inquiry. As noted by the Dhaiqirtment of Agriculture, Fisheries and Forestry in April 2011, native forest wood waste was eligible for support under the RET according to the following conditions:
Biomass energy is an important source of energy in most Asian countries. Substantial amounts of fuelwood, charcoal and other biomass energy such as agricultural residues, dung and leaves are used by households and industries. The main household applications are cooking and heating whereas industrial applications range from mineral processing
26/7/2017 · Converting Agricultural Waste for Energy Applications. Without an ecosystem of science-business partnerships to bring a new technology to the market, good science generated in the laboratory seldom sees the light of day as a commercial product. Because of key partnerships, however, Clarkson University Professor / GE Chair in Oil and Gas Systems
agricultural waste is a good option to convert these waste in energy. For this efforts have been made and many more are under way, it requires guidelines concerning the utilization of agricultural biomass for energy purpohaiqi and optimal production. Production of energy from biomass can provide
Waste from agriculture and forestry can be reused. This is how adhesives are made from waste wood or biofuel from straw. However, it is important to take a holistic view in order to avoid undesirable pollutants.You can read more about the EU research project and what to look out for in this type of reuse
29/1/2021 · “Around 8,000 tonnes of forestry and agricultural waste each year will be used to produce bio-fuels for local industry and create bio-char that farmers can use to condition their soil.”
On July 8, the Environmental and Energy Study Institute (EESI), Center for Climate Strategies (CCS) and the Office of Senator Roland Burris (D-IL) held a briefing about state climate actions related to agriculture, forestry and waste management, and how they can inform the current Congressional debate on energy and climate policy. States have developed a range of approaches for promoting
4/2/2021 · AVR, Waste-to-energy company tackles CO2 emissions with large-scale CO2 capture installation (29 May 2018). ‘Government of Western Australia, Media Statement, Nations second waste-to energy plant to be built in WA (24 December 2019). Renew Economy, Maryvale Energy from Waste project moving forward (20 October 2020).
agricultural and municipal waste to energy project Objectives and Scope The project objectives are to successfully implement Waste to Energy (WTE) projects and to apply the use of clean, reliable, and safe Municipal Solid Waste(MSW) treatment in secondary cities in the PRC, where WTE infrastructure is lacking and demand is not fully met.