E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
6/2/2020 · February 6, 2020 by admin in Uncategorized. Bamboo and its derivatives fall within the category of biomass, a biodegradable substance, essentially a product of photosynthesis and a natural solar cell storing in some form or other, solar energy, and this energy can be meaningfully extracted through application of appropriate technology.
Energy generation from residual waste provides an excellent waste management solution especially after all the waste management hierarchi- cal efforts are made and when further waste recycling is not economically viable. These mixed waste streams, commonly known as residual waste, are heterogeneous, very complex to recycle and are well suited for waste-to-energy (WtE) application. After energy
This study focused on elucidating disposable bamboo chopstick (DBC) waste generation rate and identifying the appropriate carbonization temperature for recycling DBC waste as a renewable energy resource. A survey was conducted within the study area
On the final stage, bamboo’s waste could be sent to landfill or be incinerated for heat and electricity generation (Vogtländer & Van der Lugt, P., 2014); therefore avoiding the use of fossil fuels and reducing GHG emissions.
•Clean power generation from bamboo gasification for captive use. •Treatment of bamboo poles for polyhouse structures, Cottages and Gazeboes •Bamboo roll up chicks and table mats for inhaiqiors. •Bamboo flooring tiles and bamboo Mat board for housing. •Pre fabricated wall panels for bamboo houhaiqi & other structures.
The main aim of this study was to turn bamboo waste into an energy resource by the granulation process and add value to the bamboo waste. Figure 2 is a flow diagram of the study. The hydraulic machine was used for granulation process to form pellets. The engine oil waste was used as the binder to produce a hard granular bamboo waste RDF. Different ratios (5:1, 10:1, and 20:1) of bamboo waste
Both studies and investment in bamboo plantation for energy purpohaiqi are increasing greatly. In Vietnam, energy generation from bamboo is a new concept despite the fact that Vietnam is rank fourth in bamboo production. However, efforts are undergoing to make bamboo biomass energy closer to its potential.
With a stronger commitment to improve both rural and urban energy needs, African countries could be in a better position address it perennial energy crisis through the use of bamboo biomass as an alternative source of energy. Up-scaling the development and use of energy from bamboo biomass could provide a viable market for the use of bamboo waste mahaiqials and other supplementary waste
The parts without branches and leaves go to Bamboo Mahaiqial Co., Ltd. for processing into building mahaiqials. Branched leaves and chips (and cedar bark) go to Bamboo Energy Co., Ltd., for fuel. The latter company mentioned is our end-customer, involved in the power generation business exploiting the biomass waste.
Dispose Of Domestic Waste: It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) Area (300t/D) 40-50 Acres Higher: 30-40 Acres Lower: Operating Cost Fly Ash Emissions: Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage
Bamboo Wast renewable energy from waste . Create an excellent brand of global smart energy Waste Gasification Power Plant Waste gasification power plant: capacity
The Next Generation (NSW) Energy from Waste Facility, Eastern Creek EIS Merit Review Issue | 3 August 2015 This report takes into account the particular instructions and requirements of our client. It is not intended for and should not be relied upon by any third party and no responsibility is undertaken to any third party.
1/9/2018 · The H2020 Project BAMBOO is dedicated to the development of new technologies for energy- and resource-intensive industries such as steel production, petrochemicals, minerals processing, and pulp and paper production. These technologies can be assigned to three main pillars of innovation: Waste heat recovery, flexibility of power consumption and recycling and utilization of waste streams. These
Anaergia (TSX: ANRG) is a global leader in offering sustainable solutions for the production of clean energy and the conversion of waste streams to resources. Through a proven portfolio of proprietary technological solutions, Anaergia maximizes the generation of renewable energy, diversion of waste from landfill and reduction of greenhouse gahaiqi for customers across the municipal, industrial
This study evaluated bioelectricity generation by using kitchen garbage (KG) and bamboo waste (BW) as a solid waste management option by a microbial fuel cell (MFC) method. The nutrient content [nitrogen, phosphorus and potassium (NPK)] of the by-products of bioelectricity were also analyzed and ashaiqised for their potential use as a soil amendment. A one-chamber MFC was used for bioelectricity