E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
As energy supply equipment, boilers consume a lot of energy in the daily application of printing and dyeing factory. Choosing the right boiler is a very important step in how to make the printing and dyeing plant save energy.
10/5/2021 · The first strategy is to implement the co-firing program in coal-fired power plants (haiqis) by substituting 10% of coal with biomass. The second strategy to convert 5,200 diesel-powered power plants (PLTDs) in 2,130 locations with a capacity of up to 2 gigawatts (GW) to be new renewable energy power plants.
May 19, 2020 onlinesaleboiler Leave a Comment on Air-Cooled Biomass Burner for Textile Printing and Dyeing. SHW Reciprocating Grate Boiler. Biomass Power Plant ...
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Coal Boiler For Dyeing And Printing | Biomass Boiler biomass burner for textile printing steam boiler. biomass fired hot water boiler printing and dyeing. The temperature range is 60~180, coal fired thermal oil heater for printing and dyeing mill is available for textile industry, which achieves high working temperature (330) under low working pressure (10 bar).
Coal fired boiler generates thermal energy by burning coal, while biomass boiler is similar to coal boiler by burning biomass fuel like wood chip. These two boilers are widely used in power station, chemical, textile, printing and dyeing, energy, mining, paper making, agricultural industries, etc.
The global biomass power market size was valued at USD 121,340.76 million in 2021 and is projected to exhibit a compound annual growth rate (CAGR) of 6.0% from 2022 to 2030. The market has been witnessed growth with the rise in environmental concerns, which has forced various countries to increase the share of renewable energy in their power mix.
Textile printingamp; dyeing is a relatively traditional industry.High efficiency boilers for printing and dyeing mill High efficiency boilers for printing and dyeing mill 2018-8-30 · Sitong Boiler product thousands of industrial boilers, such as oil gas fired steam boiler, biomass pellet boilers, coal fired chain
Biomass - WikipediaBiomass is haiqi matter derived from living, or recently living organisms. Biomass can be used as a source of energy and it most often refers to plants or plant Lessons Learned fr
In addition, the biomass industry diverts millions of tons of waste mahaiqial from landfills and open burns. Biomass power plants eliminate the need for frequent open burns of agricultural waste and forest slash, while continuing to offset the use fossil fuels that produce smog and acid rain. In this way, Biomass power greatly improves air quality.
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
In the dying industry, many of the proceshaiqi require heat which can be provided by steam energy produced by boilers or steam generators. 563 views. steam boiler for fabric dyeing industry steam boiler for printing and dying industry What Are The Boilers Used in Fabric Dyeing Factory- 2019-9-10 · At present, the main boiler for the textile factory is
Textile, printing,dyeing,non woven enterprihaiqi:heat setting, thermosol dyeing,bake,hot air stenter 600, 000 Kcal Wood Chip and Particle Burners for Coal-Fired Boilers Reform Wood - Chip Biomass Burner for Reformation of Industrial Kiln hot air stove furnace. Read More; About Us - GreenVinci Biomass Energy Co.,Ltd. 1. CE certification for hot
20/1/2019 · much as 60% of the textile dyeing industry’s energy costs. Therefore, the opportunity to use biomass . as an alternative energy source brings many advantages for this industry [28, 29
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.