E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Vojnotehnički glasnik. 2015, vol. 63, iss. 1, pp. 102-113
Biomass fuels are typically used most efficiently and beneficially when generating both power and heat through cogeneration / CHP systems. The industrial sector currently produces both steam or hot water and electricity from biomass in CHP facilities in the paper, chemical, wood products, and food-processing industries. These industries are major users of biomass fuels; utilizing the heat and
Cogeneration Combined heat and power CHP Cogen. 2019-8-21 · Cogeneration Combined heat and Power (CHP) Cogeneration (cogen) through combined heat and power (CHP) is the simultaneous production of electricity with the recovery and utilisation heat.Cogeneration is a highly efficient form of energy conversion and it can achieve primary energy savings of approximately 40% by compared to the
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
production of power and steam from one fuel source. Jobs in the Forests, Jobs in Town The Lakeview Biomass Cogeneration Plant will create good jobs in a part of rural Oregon with an unemployment rate above the state average. The plant’s construction will have a major impact on the local and regional economy, from contracting, engineering
Cogeneration is the simultaneous production of electricity and heat using a single primary fuel. Biomass cogeneration uhaiqi waste wood and horticultural mahaiqials as fuel. T hese are plants that derived their growth and energy from the sun, converting carbon dioxide into oxygen. This biomass green energy reduces use of fossil fuels. The
Cogeneration is currently used on many thousands of sites throughout the EU, and supplied around 10% of both the electricity generated and heat demand in the EU-15 in 1999. The EU target is to reach 18% by 2010. The following table illustrates what this target could achieve in terms of CO2 emissions reduction. The results are different depending on the fuel being displaced:
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Biomass Cogeneration Our heating solutions can be used in a cogeneration process, to produce a combination of heat and electricity from biomass. This type of solution is extremely energy-efficient and is of great benefit to energy-intensive industries, which require both heat and electricity for process use.
1/9/2021 · The scarcity of fossil fuels and environmental pollution prompted the search on new renewable fuels. Sweet sorghum has succulent stems and broth similar to sugarcane, but studying its energy potential is necessary. We evaluated the biomass, grain yield, ethanol production, and energy cogeneration of sweet sorghum cultivars irrigated with raw and diluted domestic sewage effluent. The experiment
Biomass Cogeneration – alternative approaches feed Biomass combustion or gasification Power unit Electricity Process heat (steam, hot oil, hot water) 7 2. Productive use of waste heat from power unit • Different heat and power needs to previous examp
29/4/2011 · The MU plant currently uhaiqi 10 percent woody biomass—trees and woody plants such as limbs, tops, needles and leaves—but it plans to replace one of its coal-burning boilers with one that uhaiqi 100 percent biomass by next year. The new boiler will use 100,000 tons of biomass from in-state sources including woody biomass, grashaiqi, waste papers and agriculture residue. MU will be able to use
Four groups of technologies that can be used for biomass valorisation have been considered in the paper; biofuels production, thermal power plants, district heating and cogeneration. The proposed
11/2/2015 · Power production and combined heat and power production from biomass is a form of renewable energy that has gained significance and is expected to grow steadily over the coming years. Because of fundamental differences in properties between biomass and traditional fossil fuels for power generation, biomass power plants source their fuel mostly locally and their capacity is restricted by local
CHP units have better total efficiency than conventional energy systems, since better exploitation takes place and energy is used for the production of heat as well. Electricity and heat can be generated in a large variety of scale. Usually, the environmental performance of CHP biomass plants is good, compared to fossil fuels. Theoretically, if biomass is grown in a sustainable, carbon-neutral