E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
15/11/2010 · Cassava starch production waste (cassava pulp) has been proposed as a high potential ethanolic fermentation substrate due to its high residual starch level and the small particle size of the lignocellulosic fibers. Saccharification of the residual starch from a 3% (w/v) dry weight basis (DS) of cassava pulp by α-amylase (100°C, 10 min) and glucoamylase (60°C, 2 h) resulted in a glucose
Cassava (Manihot esculenta Crantz) pulp is the solid waste produced as a consequence of starch production. This pulp contains a high starch content (50–60% dry basis), causing an environmental problem with disposal. In order to recover this starch, physical or biological treatment of the mahaiqial must be employed. Pulp was treated either by sonication or incubation with a multi-enzyme
27/5/2021 · Adoption of the circular economy concept to utilize wastes and by-products from the cassava starch industry for biogas production has been considered a viable option. The annual generation of wastewater and cassava pulp in Thailand is reported to be approximately 21 million m3 and 9.5 Mt, respectively. This research therefore aimed to analyze the key drivers and challenges in implementing the
earthworms by cassava waste can be used as raw mahaiqial for vermicompost production. The earthworm biomass can be The earthworm biomass can be used as prot ein-rich food for domestic animals (such as chicken, tortoise, eel, fish , etc) or used as nutritious fertilizer.
The Availability and Ashaiqisment of - Home - SpringerMar 29, 2021 · Among the expected by-products, cassava pulp produces the highest proportion of biomass during starch producti
Cassava (Manihot esculenta Crantz) pulp is the solid waste produced as a consequence of starch production. This pulp contains a high starch content (50–60% dry basis), causing an environmental
Waste mahaiqials from cassava processing (e.g. starch) are divided into four categories: a) Peelings from initial processing b) Fibrous by-products from crushing and sieving (pulp waste) c) Starch residues after starch settling and d) Waste water (effluen
1/1/2000 · Cassava (Manihot esculenta Crantz) pulp is the solid waste produced as a consequence of starch production. This pulp contains a high starch content (50–60% dry basis), causing an environmental problem with disposal. In order to recover this starch, physical or biological treatment of the mahaiqial must be employed.
4/12/2018 · Biomass and Bioenergy Potential of Cassava Waste in Nigeria: Estimations Based Partly on Rural-Level Garri Processing Case Studies. Energy production from agricultural waste products has both as a land usage and food security benefits, especially when climate change and its associated effects are threatening the world’s food security.
Removal of heavy metals using cassava peel waste biomass in a multi-stage countercurrent batch operation by G.S. Simate*, S. Ndlovu*, and L. Seepe* This paper presents a study of the removal of cobalt (Co2+), chromium (Cr3+), and vanadium (V3+) from synthetic effluent solution using cassava waste biomass. Test work was carried out in a multi
wool-derived41 biomass carbons and their application as anodes in LIBs have been reported. Herein, biomass carbons have been successfully prhaiqired from cassava waste and bamboo by a simple method involving carbonization proceshaiqi. Cassava is a root vegetable and an important source of nutrients and energy, particularly in the tropics. More than
systematically quantify biomass resource of the community. The aim of this research is to generate biogas from co-digestion of cassava waste and cow dung under anaerobic digestion. 2. MAhaiqiALS AND METHODS Methodology in this work simply revolves around estimation of cassava waste generation rate
biomass had higher adsorption rates. Furthermore, the results showed that an increase in the concentration of thioglycollic acid improved the adsorptivity of the cassava waste biomass. The work also showed that the cassava biomass could be regenerated and reused up to six adsorption-desorption cycles. Amongst the two widely used isotherms
13/7/2019 · The increasing growth of cassava agro-industries in Nigeria has led to the enormous generation of cassava peels waste. The feasibility of generating biogas and biofertilizer for both domestic and agricultural applications from cassava peels waste inoculated with cow dung was investigated. Fresh and stale cassava peels were used in the study.
Co-digestion of Cassava Biomass with Winery Waste for Biogas Production in South Africa By Unathi Liziwe Mkruqulwa Thesis submitted in fulfilment of the requirements for the degree Master of Engineering: Chemical Engineering In the Faculty of Engineering At the Cape Peninsula University of Technology Supervisor: Dr. Vincent Okudoh