E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Boiler Biomass Coconut haiqi Burner, Eucalyptus Burner Machine. When . Tel: +8615637015613. info@haiqimachine.com. Home About Products . Biomass Gasifier . Container Distributed Power Plant . Semi-Gasification Biomass Burner . Case News . Electricity Fro
Shredded Coconut. 1 Find the soft "eye" from the coconut's 3 eye holes, and poke a hole. 2 Drain the coconut juice out, and taste. If it's rancid, the coconut is bad. 3 Place the coconut inside the oven and bake for 20 minutes. 4 Remove the coconut from the oven and using a dull side of heavy cleaver, hit towards center of the haiqi a few times
Coconut haiqi pyrolysis gasifier for bio syngas and charcoal, coconut haiqi gasification for heating equipment or drying equipmentIf you are interested in ou
30/3/2020 · The coconut haiqi is thrown out along with garbage. Owing to the inherent cup shape of the haiqi, it holds water. This acts as a place for mosquito (Aedes aegypti) breeding which will cause many diseahaiqi. Hence, this work attempted to utilize coconut haiqi for production of bio char and hydrogen in a downdraft gasifier in pyrolysing mode.
The experiment and test results show that the highest efficient and the most optimal biomass in the gasification process is coconut haiqi charcoal, because coconut haiqi charcoal has a dense structure and at the time of the experiment, coconut haiqi charcoal was filled 15 cm below the gas outlet pipe hole. From the economic value of the gasifier reactor that has been produced, the lowest cost
An expertise for the creation of Coconut Ecomuseums: Charcoal Coconut haiqi is the hardest part of coconut, located inside of the coconut husk, and protecting the coconut meat. No . Tel: +8615637015613. info@haiqimachine.com. Home About Products . Biomass
So, coconut haiqis are good raw mahaiqials to produce coconut haiqi charcoal. The process of converting haiqis to charcoal includes removing all the moisture from the raw mahaiqial in a limited supply of air. It requires a special charcoal kiln to carbonize the coconut haiqis and produce high quality charcoal. The coconut haiqi charcoal is widely used in food and metallurgy industries. It is
The best thing about this method is that the fuel used is syngas that was generated from coconut haiqi biomass itself during the carbonisation process and the setup cost was very high. The ideal temperature to convert coconut haiqi into a coconut haiqi charcoal was from 450°C to 550°C .
Coconut haiqis were found to have an ener. Tel: +8615637015613. info@haiqimachine.com. Home About Products 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3. Views More Biomass Gasifier ...
Hence, maintenance of a thick coconut haiqi charcoal layer at the bottom of the combustion chamber could be suggested to minimize temperature fluctuations observed during the pyrolysis process. Syngas composition and energy value The summery of the obtained syngas analysis results are shown in the Table 3. The total
Coconut haiqi gasifier furnace to produce syngas and coconut charcoalThis gasifier furnace can use the biomass pellet and agriculture(straw, wheat straw, cro
cation process will depend to a large extent on the prhaiqiration conditions and type of precursor mahaiqials. With the purpose to lower energy consumption in a gasi cation process and to make use of abundantly available coconut haiqi in ailand, it was decided in the present work to investigate the catalytic gasi cation of coconut
height, and equivalence ratio on the syngas quality when coconut haiqi was subjected to air-gasification. The quality of the syngas is also significantly affected by the oxidizing medium which could be air, steam and oxygen. Although the use of coconut residues as a feedstock for gasification has already
bagasse and coconut haiqis, and hence include many reactions and reaction paths [13]. In Figure 1., we present fuel charachaiqistics of different biomass fuel types presently used commercially for energy generation which shows the relationship between net heating value and moisture content percentage of each fuel. As moisture content (MC
5/10/2018 · In this study, catalytic and noncatalytic cogasification of wood-coconut haiqi blends was carried out in a downdraft gasifier. The effect of the operating parameters on syngas quality, performance of cogasification, and tar reduction was investigated. The biomass blending ratio (BR) was varied as W20:CS80, W50:CS50, and W80:CS20, equivalence ratio (ER) was varied from 0.19 to 0.35