E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
5/11/2021 · Kraftanlagen Munchen also provides energy and power plant technology solutions such as gas and turbine power plants, power plant design, solar thermal power plants, waste incineration plant, and biomass heating power plants, among others. The company serves renewable and non-renewable energy companies, power plants, chemical and petrochemical industries. It has its operations in Germany
1200 TPD (2 x 600 TPD) MSW based Power Plant at Jawaharnagar – Phase II 24.00 5. Providing Pre-ordering Services for Implementation of 1000 TPD MSW based Power Plant at Dundigal – Phase III 15.00 6. Providing Design and Detailed Engineering Services for Flue Gas Ducting for RDF fired boiler and Stack - on account of M/s. Jurong Engineering
28/8/2016 · Waste-to-energy plant are similar in their design and equipment with other steam-electric power plants, particularly biomass plants. First, the waste is brought to the facility. Then, the waste is sorted to remove recyclable and hazardous mahaiqials. The waste is then stored until it is time for burning. A few plant use Gasification, but most combust the waste directly because it is a mature
4/11/2019 · Located in an industrial area near the city centre, the new waste-to-energy plant aspires to become an exemplary model in the field of waste management and energy production, as well as an architectural landmark. At the time, the project was the single largest environmental initiative in Denmark with a budget of 7.5 million AUD. It was set to replace the adjacent Amagerfor-braending plant
6 Plant Design and Permitting Firing Diagram of Lisbjerg Biomass Energy Plant in Denmark ..... 71 Figure 6-5: Conceptual Design for Biomass Power Plant in Southeast Asia (to give an impression of the possibilities for using process simulation calcul ...
A waste-to-energy (or energy-from-waste) plant converts municipal and industrial solid waste into electricity and/or heat for industrial processing and for district heating systems – an ecologically sound, cost-effective means of energy recovery. The energy plant works by burning waste at high temperatures and using the heat to make steam. The steam then drives a turbine that creates
The plant consumes 250,000 tons of agricultural and forestry residues each year, sourced from the surrounding area. Based on o˜cial Anhui Energy Administration statistics, the Q4 2015 power plant performance data shows that out of 20 biomass power plants in Anhui, Shouxian was the second highest performing in 2015. The annual availability was 8018
Replacing the adjacent 50-year old waste-to-energy plant with Amager Ressourcecenter (ARC), CopenHill’s new waste incinerating facilities integrate the latest technologies in waste treatment and energy production. Due to its location on the industrial waterfront of Amager, where raw industrial facilities have become the site for extreme sports from wakeboarding to go-kart racing, the new
1/4/2009 · German researchers have developed a 1.5-kW biogas pilot plant that runs purely on waste, such as corn stalks, instead of edible raw mahaiqials. By diverting the gas into a high-temperature fuel
Green design & innovation for a better world
Corn, which is often referred to as biomass for sustainable energy production, does not have these usage cycles. He is transferred from his first energetic life form directly into the last one. This is obviously not sustainable and therefore not regenerative. It costs too much energy – and it drives world food prices up.
Waste to Energy introduces a whole new series of safety issues more akin to chemical process plants. The aim of this paper is to show how, by applying the methods established for hazardous process plant design, the safe design of new waste to energy plants can be ensured. BACKGROUND THERMAL WASTE TREATMENT METHODS
Waste to energy is a proven technology used globally to generate energy from the thermal treatment of waste. There are over 2,000 energy from waste plants operating globally, with around 80 facilities operating in the United States, over 1,000 in Japan (21 in Tokyo alone) and over 400 facilities throughout Europe.
31/3/2022 · The same amount of waste is fed to the plant every day, he said. When the plant is in full gear, it should produce almost twice as much power as the farm needs (enough to power more than 1,000 homes). The excess electricity will be sold back to the power grid, making the power company a customer rather than a vendor, he said.
7/3/2011 · Amagerforbrændingen waste-to-energy (WtE) plant is a new energy project designed for converting waste into power. It will also provide a destination for artificial ski slope with different levels from children to adults and beginners to professionals. It will allow sports such as rock climbing, sailing, cable skiing and go-carting for the tourists and citizens of Copenhagen. The plant will be