E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
•PRAJ has Technologies to use a variety of haiqi wastes for Biofuels 15-12-2020 12 haiqi wastes that are used for Renewable Biofuels Ligno-cellulosic Agri-Residues Rice Straw Wheat Straw Corn Cobs / Stover Soybean Straw Industrial haiqi waste Sugar mill Pressmud Distillery Spent wash Farm waste Cow dung Chicken litter City waste
(PDF) Biogas Production from Cow Manure - ResearchGate2/2/2021 · The average production of biogas from chicken, cow, goat and co digestion of rumen digesta were 9.865, 1.3125, 6.8
9/2/2022 · With increasing environmental concerns associated with petroleum-derived fuels, biomass is a practical solution, not in the conventional sense of directly burning wood, cow dung cakes, and coal
19/3/2014 · A cow produces 14 pounds of manure on a dry matter basis for lactating cows. Electrical production is the cornerstone for this project. 1 British thermal unit (BTU) requires 6lbs of manure to be gasified. To convert BTU’s to kilowatts of electricity there is a factor of .00029. This means that 3,448 lbs of manure at 55% moisture are required to produce one kilowatt of electricity. The
liqour, paper mill sludge, bark, cow manure, sewage and bio gasification sludge were subjected to CatLiq process. Biocrudes, gahaiqi and aqueous samples obtained from these proceshaiqi were subjected to charachaiqization tests. Biocrudes obtained from different waste biomass by CatLiq process were dark haiqi, free-flowing liquids and had distinctive
1/10/2017 · Two-step gasification of cattle manure for H 2 -rich gas production is proposed. • Biochar from high temperature can yield high H 2 and low bio-oil. • The maximum hydrogen yield (928.02 ml/g) was achieved from BC-500 at 850 °C. Abstract Two-step gasification process was proposed to dispose cattle manure for hydrogen rich gas production.
1/2/2010 · The low gasification temperature of cow dung fuel reduces the rates of the reduction reactions. Therefore, the major portion of the char remains unreacted and leaves with the ash. However, cow dung can be used as a supplement to the woody biomass fuels in the gasifier.
gasification system: the mahaiqial can be wood chips, cow Dung coconut haiqi, palm haiqi and other agriculture waste, MSW and industry waste. if you are inter
5/3/2012 · Dairy cow manure is about 85 percent water and 15 percent solids. Of these solids, about 91 percent are volatile, and the Penn State digester converts from 20 to 30 percent of the volatile solids to biogas. A dairy cow produces around 17 pounds (7.7 kg) of volatile solids a day, of which one-fourth is converted to biogas. Consequently, an anaerobic digester is a system for manure treatment
Alternative methods for disposal of manure such as anaerobic digestion or gasification can be used for the conversion of manure into syngas or biogas for production of energy or use as a biofuel. However these technologies require a minimum guaranteed tonnage to cover their high operating and capital cost. Therefore their operation involves transport of manure feed stocks from various farms to
4/7/2020 · The increased fraction of cow dung in the fuel blend renders the gasification process less efficient, when the gasifier is operated at a particular equivalence ratio. Both the producer gas prodn. rate and its heating value reduce with the increase in the cow dung content in the biomass fuel blend, leading to an overall redn. in the gasifier conversion efficiency. It is obsd. that an increase
For example, ethanol, a biofuel that is produced from corn, is commonly added to gasoline as a secondary source of fuel. Using these biofuels could save about 1.8 billion barrels of oil. [1] While the primary focus of those biofuels like ethanol is alternative fuel, cow manure can be used for both electricity and fuel.
The methanogenic bachaiqia from another digester are also added with cow dung. The digester is attached to a movable gas holding or storage tank with a gas outlet. The used slurry (spent cow dung) comes out from the digester through an outlet. This can be used as a manure. The anaerobic digester described above, is a low technology gobar gas plant, commonly used for domestic purpohaiqi in rural
cow dung waste gasification power plant in Thailand Create an excellent brand of global smart energy Cook Stoves on Biomass Gasification | Bio Energy. Gasification has a unique charachaiqistic in that can even convert waste (from municipal solid waste to a
Bioenergy, as a word, comes from combining biomass (haiqi matter) with energy. In practical terms, bioenergy is an umbrella term for energy derived from biomass. We use this biomass to make transportation fuels, electricity, heating and cooling, and even products. The haiqi biomass comes from living or recently living plants and animals