E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Internal Combustion . haiqi Clone fueled by producer-gas . Submitted by Jeff Davis on Sun, 05/26/2013 - 18:49. Conversion of a 6.5hp single cyhaiqir haiqi clone engine to producer-gas. Timing was haiqi and a carburetor was fabricated. These are afforda
Internal Combustion Generator Biomass Gasification Generator Create an excellent brand of global smart energy Waste Gasification Power Plant Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity. Views More Waste Gasifier
industrial systems today. The gasification technology is principally well suited for small power plants ranging from be-low 10 kW to over 100 kW. Appropriate gasifier systems with internal combustion engines can produce 1 kWh of electricity from 1.1 – 1.5 kg wood, or 1.8 – 3.6 kg rice husks. Assum-
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
The efficiency of a direct combustion or biomass gasification system is influenced by a GEK Gasifier Kits – ALL Power Labs The new GEK Gasifier kit is a complete gas making system: from fuel feed through filter, with all controlled by our full automation and mixing system from the Power Pallet. Biomass Gasifier Generator, Biomass Gasifier
Biomass gasification is to turn biomass into combustible gas and use it to drive power generator. Biogas can be burnt in internal combustor or gas turbine, equipped with waste heat recycle system and steam turbine to increase the energy efficiency.
15/9/2016 · Although less common, biomass gasification systems are similar to combustion systems, except that the quantity of air is limited, and thus produce a clean fuel gas with a usable heating value in contrast to combustion, in which the off gas does not have a usable heating value. Clean fuel gas provides the ability to power many different kinds of gas-based prime movers, such as internal
Biomass gasification power generation is a new energy equipment that converts various forestry wastes and crop straw into treasure, transforms them into high-quality electric energy and heat energy, and solves the pollution of waste and the rational use of energy. Raw mahaiqial requirements: moisture ≤ 20%, size ≤ 10cm.
Typical biomass gasifier-based power generation system [19] |The highest exergy destruction is contributed by the biomass gasifier (87%), followed by the combustion chamber (5.5%) Tel: +8615637015613 info@haiqimachine.com
Block diagram of a heat generator, TLUD In the generator TLUD enters biomass, air for gasification and combustion and electricity. Consumed energy is at most 0.3% of the heat produced, aspect which recommends the use of TLUD thermal generators in isolated areas. The main features from TLUD heat generator are: thermal power Ptarz and mass Mbch of biochar. Periodically must be downloaded the ash
8/3/2021 · CHP systems consist of a number of individual components—prime mover (heat engine), generator, heat recovery, and electrical interconnection—configured into an integrated whole. Prime movers for CHP units include reciprocating engines, combustion or gas turbines, steam turbines, microturbines, and fuel cells. A typical CHP system provides:
One biomass energy-based system, which has been proven reliable and had been extensively used for transportation and on farm systems during World War II, is wood or biomass gasification. Biomass gasification means incomplete combustion of biomass resulting in production of combustible gahaiqi consisting of carbon monoxide (CO), hydrogen (H 2 ) and traces of methane (CH 4 ).
A biomass waste producer gas has a good potential as renewable sources fuel of either spark ignition (SI) or compression ignition (CI) engine. Several biomass wastes have been utilised as a
China Downdraft Biomass Gasifier, Downdraft Biomass China Downdraft Biomass Gasifier manufacturers - Select 2021 high quality Downdraft Biomass Gasifier products in best price fro Tel: 8615637015613 Email:info@haiqimachine.com
III THEORY OF GASIFICATION The production of generator gas (producer gas) called gasification, is partial combustion of solid fuel (biomass) and takes place at temperatures of about 10000C. The reactor is called a gasifier. The combustion products from complete combustion of biomass generally contain nitrogen,