Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
|Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology|
|Compare Content||Grate Furnace||Pyrolysis Gasifier|
|Incineration Mechanism||The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General||Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced.|
|Furnace Structure And Grate Material||The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High||The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low|
|Types Of Garbage||Dispose Of Domestic Waste||It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste)|
|Area (300t/D)||40-50 Acres Higher||30-40 Acres Lower|
|Operating Cost Fly Ash Emissions||Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage||Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly|
|Acidic Substance And Dust Emission||The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3||The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3|
|Plant Environment||It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution.||The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low|
23/2/2015 · The 12 MW Biomass Power Plant would be built on a six-hectare property in Bagac, Bataan. It will utilize Giant Napier Grass (GNG) as its primary feedstock, to be sourced from a new dedicated plantation, which will be managed and operated by CEC’s sister company Greenday Agri Farm. The plantation would be in close proximity to the biomass
Biogas production potential of napier grass Napier grass is a complex mahaiqial that is composed of cellulose, hemicellulose and lignin. Commonly, cellulose and hemicellulose primarily contain glucose and xylose, respectively. They can be fermented to produce renewable energy using several microbial proceshaiqi . As shown in Table 1, the maximum
Grass as fuel runs biomass gas plant - haiqi Energy May 20, 2014 BACOLOR, Pampanga – Mayor Jose Maria Hizon said a global renewable energy company will build a Biomass Gasifie
Methanothrix sp. Overall energy production from Napier grass hydrolysate and the solid fraction of pretreated Napier grass co-digested with swine manure was 7.99 kJ/g-VS added. Keywords: methane, anaerobic co-digestion, agricultural residues, energy produ
Being a high yield plant, Napier grass is a good resource of biomass raw mahaiqials for fuel production. Napier grass is more efficient as a raw mahaiqial for the fuel production compared to other raw mahaiqials. This is because it requires low input of nutrients/fertilizer, it is high yield but with low cost, it requires no special care or pesticide and it are easy to grow.
10/8/2021 · Energy For All is aimed to encourage busineshaiqi and communities to jointly invest in biomass and biogas-based power generation projects. The two projects, each with capacity of 3MW based on napier
16/8/2019 · The life cycle analysis of the Napier grass-fired CHP plant with the nominal capacity of 13 MWe estimated the energy usage in the range of 2.6 × 10 8 MJ total and 1.9 × 10 8 MJ total for the Napier grass pellet and bale system, respectively. Although the EROI of the CHP plant was not as high as the fossil fuel-based proceshaiqi (Sc1: 4.3 and Sc2: 5.8), the overall GHG emission in Napier grass
Napier Grass 68 - 72 3 - 4 25 - 27 34 - 36 17 - 19 71 -73 135 to 155 All figure in % by weight of dry matter except moisture & Volatile solids Biogas yield depends on convertible Volatile solids content as well as their nature / composition The composition of Napier grass can vary depending on variety and the days of harvesting.
The Energy Ministry is actively supporting community-based biomass power plants in region, which has plenty of agricultural land but little in the way of water resources. Energy crops such as Napier grass, are low-cost, low-maintenance, and need very little water. The Ministry will fund power plants in areas that have the resources, with the farmers selling the crops to the plant and receiving
The study indicates that Mott grass or Napier grass based on its high biomass yield is an effective approach in maintaining the fodder quality for animals on the sustainable basis and being bioenergy crop could make it a viable asset in declining the carbon burden off from environment and fulfilling the upcoming energy demands.
24/4/2015 · Study on Napier grass leaf (NGL), stem (NGS) and leaf and stem (NGT) was carried out. Proximate, ultimate and structural analyhaiqi were evaluated. Functional groups and crystalline components in the biomass were examined. Pyrolysis study was conducted in a thermogravimetric analyzer under nitrogen haiqiphere of 20 mL/min at constant heating rate of 10 K/min. The results reveal that Napier grass
-. Due to the fact that Napier grass is an energy source of high heating value (average of 16 MJ/kg), it is widely used as a solid fuel source for industries. Moreover, in the AEDP 2013 plan, Thailand intended to use Napier grass to produce biogas as fuel for the production of electricity, of which it expects to produce
In irrigated areas, napier grass provided up to 438-500 tons of fresh biomass ha-1 after harvesting 5-6 times per year. One ton of napier grass can produce 90 m3 of biogas. The heating value for
27/11/2018 · Napier grass as a source of biomass energy in the Philippines is indeed promising. Nowadays, there were several companies are eyeing to establish Napier plantations for biofuels. Establishing Napier grass plantation and biomass industry in general address the needed development and optimal use of the country’s sustainable energy agenda to roughly triple its capacity for generating energy
Bio-oil Production from Napier Grass Using a Pyrolysis ProcessThe comparative potential of energy conversion and the cost of production among bio-oil, bio-ethanol, biogas and syng