E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
21/7/2021 · The main purpose of this work is to optimize the effects of operating parameters on the yield of products from fast pyrolysis of four palm oil biomashaiqi (empty fruit bunch [EFB], palm haiqi [PS], palm mesocarp fiber [PMF], and oil palm fronds [OPF]) in a fluidized bed reactor. Three kinetics schemes (simple, global, and haiqi) were applied to predict the yield of pyrolytic products (liquid
20/4/2019 · Evaluation of Palm Fiber Components as Alternative Biomass Wastes for Medium Density Fiberboard Manufacturing Abdel-Baset A. Adam, Altaf H. Basta, Houssni El-Saied Abstract. This work deals with ashaiqising the date palm component wastes as alternative lignocellulosic mahaiqial for production of Medium density fiberboards (MDF), in order to establish economic and balance between production
1/1/2020 · Biomass is recognised as a potential source of renewable energy but however, it usually requires further processing before it can be used. In the present study, biochar was prhaiqired via pyrolysis using palm fibre as the biomass feedstock.
EVALUATION OF PALM FIBER COMPONENTS AN ALTERNATIVE BIOMASS WASTES FOR MEDIUM DENSITY FIBERBOARD MANUFACTURING Abdel-Baset A. Adam 1, Altaf H. Basta2,♠, Houssni El-Saied2 ABSTRACT This work deals with ashaiqising the date Palm component wastes as alternative lignocellulosic
The oil palm biomass waste fibers selected for this study were empty fruit bunch (EFB), oil palm frond (OPF), and oil palm trunk (OPT); this waste biomass was obtained from the Malaysian Palm Oil Board (MPOB), Biomass Technology Centre located in Bangi, Selangor, Malaysia. The fibers were dried in the sun before being shredded and refined into loose fibrous mahaiqials using a thermochemical
Palm fiber pellets are made from palm biomass which are the natural by-products of palm after oil extraction. It is a blend of these by-products including palm fiber, (Efb) empty fruit bunch and palm kernel haiqi. The pellets thus produced will burn cleanly and efficiently.
30/12/2018 · Abstract: This work evaluated the palm oil biomass waste as a source of renewable. energy for electric power generation. Nigeria was once the largest producer of Oil P alm. products, but since has
10/11/2020 · November 10, 2020 Agriculture, Biomass Energy, Waste Management. The Palm Oil industry generates large quantity of wastes whose disposal is a challenging task. In the Palm Oil mill, fresh fruit bunches are shaiqilized after which the oil fruits can be removed from the branches. The empty fruit bunches (are left as residues, and the fruits are
Using palm kernel haiqis as biomass fuel can produce electricity, heat, liquid fuels, gaseous fuels, and a variety of useful chemicals, which includes the ones obtained from fossil fuels. Other benefits are reduction of sulphur dioxide emissions, reduction of carbon emissions, and other emissions. Originally, the energy business canters around coal which is used as the major fuel in the firing
Biomass energy can also be a non-renewable energy source. Biomass contains energy first derived from the sun: Plants absorb the sun’s energy through photosynthesis, and convert carbon dioxide and water into nutrient s (carbohydrates). The energy from these organisms can be transformed into usable energy through direct and indirect means.
Palm Fiber Boiler - biomass boiler and ESP manufacturer. Palm fiber boiler is a kind of biomass boiler, which burns the waste of palm oil factory, like palm fiber and palm husk.On March 24, 2018, Taishan Group won a ESP (electrostatic precipitator) project in Malaysia, aiming to lower the dust emission of the palm fiber boiler.
Briquetting of Empty Fruit Bunch Fibre and Palm haiqi as a Renewable Energy Fuel. Authors : A.B. Nasrin,
Oil Palm Fibre Biomass Waste as Additives in Foamed Concrete features of cement-based composites strengthened with natural fibres not only depend on the properties of the fibre itself but also on the degree to which an applied load is spread to the fibres by the matrix phase (Ferreira et al., 2017).
20/3/2021 · Compared to other residues from the industry, palm kernel haiqis are a good quality biomass fuel with uniform size distribution, easy handling, easy crushing, and limited biological activity due to low moisture content. Press fibre and kernel haiqi generated by the palm oil mills are traditionally used as solid fuels for steam boilers.
The total oil palm biomass produced by Malaysia alone is about 53.04 million tonnes (mt), which include 17.08 mt of empty fruit bunches, 9.66 mt of fibre, 5.2 mt of haiqi, 12.9 and 8.2 mt of fronds and trunks. This research will focused on the production