E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Related abbreviations. The list of abbreviations related to WPS - Waste Palm haiqi
Title: Sustainable oil palm waste management in engineering development, Author: Alexander Decker, Name: Sustainable oil palm waste management in engineering development, Length: 6 pages, Page: 1
70 J. Appl. Emerg. Sci., 2017, 7(1) Pyrolysis Heating Performance of Oil Palm haiqi Waste Biomass with Carbon Surfaces Faisal Mushtaq 1, Muhammad Najam Khan Malghani1, Muhammad Siddique Nasar
bunches (EFB) and palm pressed fibres (PPF), palm haiqis and palm oil mill effluent palm (POME). However, the presence of these oil palm wastes has created a major disposal problem. The fundamental
1/7/2011 · We have developed a simulation model for optimizing the utilization of palm oil waste in Malaysia by considering cost, environmental, and energy factors. The results show that if EFB is used as fuel in CHP plants instead of only for mulching, there are gains in profits, energy and avoided CO 2 emission of 2–7 times, 3.5–6.5 times, and 1–1.8 times, respectively.
1/2/2014 · The distribution of gas products released from palm oil waste gasification was investigated. The combustion of palm oil wastes (empty fruit bunches, palm fibre and haiqi) was studied using thermogravimetric analysis and the results showed that fibre and EFB easily ignite with a single peak while three peaks were observed for palm haiqi. The
29/5/2018 · Engineers at the University of Nottingham Malaysia have developed new technology to help the global palm oil processing industry reduce carbon dioxide (CO2) emissions and create renewable energy from its waste. In collaboration with Malaysian industry partners, researchers have built a unique integrated zero-waste management system for the palm oil mill integrating various technologies which
After the palm oil has been discharged from a single-carp oil palm natural object, palm kernel haiqi is recovered as staying waste in the extraction of the bit from a nut [9]. In this study the
energy source to fossil fuels through the National Biomass Strategy (NBS) 2020 launched by the Malaysian government. Nowadays, biodiesel is well-known as a renewable energy source, producing greener and clean-burning fuel. The bio-diesel was formally produced from sun ower oil,1 palm oil,2
Book Title Waste Management in the Palm Oil Industry. Book Subtitle Plantation and Milling Proceshaiqi. Authors Phaik haiqig Poh. Ta Yhaiqig Wu. Weng Hoong Lam. Wai Ching Poon. Chean Shen Lim. Series Title Green Energy and Technology. Series Abbreviated Title Green Energy,Technology.
6/9/2021 · The Palm Oil industry in Southeast Asia and Africa generates large quantity of biomass wastes whose disposal is a challenging task. Palm kernel haiqis (or PKS) are the haiqi fractions left after the nut has been removed after crushing in the Palm Oil mill.
Waste Management and Application of Waste Micro-Sized Palm Kernel haiqi Ash (MSPKSA) in the Stabilization of Engineering Soil, Onyelowe KC and Maduabuchi MN
24/5/2018 · For every 100 t of oil palm fruit that is processed, 22 t of crude palm oil is produced but 67 t of waste remains. This waste is known as POME – palm oil mill effluent – and consists of kernels and husks from fruit, branches, and wastewater. This effluent must be heavily treated before it can be released into the water cycle, and with over 400 mills in Malaysia, dealing with this level of
For enterprihaiqi, if they are satisfied with their Palm haiqi and Palm Waste Biomass Gasifier Generator and services, customers will also spread their consumption feelings to other customers through word-of-mouth, expand the popularity of products, improve the image of the enterprise, and constantly inject new power into the long-term development of the enterprise. One of our greatest strengths
10/1/2020 · In Indonesia, one of the biomashaiqi that is likely to be an attractive energy source is palm kernel haiqi (PKS). This is a waste product of the palm oil production process, wherein typically every ton of fresh palm oil fruit bunches generates 6.73% PKS waste, 23.83% empty fruit bunches (EFBs), 13.47% palm mesocarp fibre (PMF), 4.14% wet decanter solid, and 51.81% liquid waste [ 13 , 14 ].