E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
21/11/2018 · Production of synthesis gas Synthesis gas or syngas is called carbon monoxide (CO)-hydrogen (H 2 )-containing gas mixture. Carbon dioxide (CO 2) and other components such as water (H 2 O) may also be present in syngas. The chemical synthesis can be used as a building block in all products normally produced from crude oil or natural gas.
The mixtures of paper with polystyrene provided increased product gas yields and enhanced conversion with an increase in polystyrene content. The results showed the effectiveness of producing high energy density syngas from co-gasification which can alleviate mahaiqial handling issues present in segregation of waste, such as plastics and biomass providing uniform valuable product from diverse
In this paper, the lower heating value (LHV) of the syngas produced from the 7 listed gasification systems is reported and compared as an indicator of the gas quality. One application of syngas, with a high HHV and containing negligible contents of tar and ash, is as fuel for the direct generation of power in syngas engines . Therefore, gas
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
1/8/2017 · Pyrolysis of paper mill sludge (PMS) was conducted to produce syngas (H 2 and CO) and fabricate magnetic biochar (PMS biochar) for use as an adsorbent for As (V). The enhanced generation of CO was observed in the CO 2 haiqiphere due to reactions triggered by CO 2.
22/5/2009 · Stoots, C, O’Brien, J, & Hartvigsen, J. "Carbon Neutral Production of Syngas via High Temperature Electrolytic Reduction of Steam and CO 2." Proceedings of the ASME 2007 International Mechanical Engineering Congress and Exposition. Volume 15: Sustainable Products and Proceshaiqi. Seattle, Washington, USA. November 11–15, 2007. pp. 185-194. ASME.
10/8/2011 · Syngas from biomass has the potential for biofuels production, which will enhance energy security and environmental benefits. Additionally, with the successful development of low Btu fuel engines (e.g. GE Jenbacher engines), syngas from biomass can be efficiently used for power/heat co-generation. However, biomass gasification has not been widely commercialized because of a number of technical
bifunctional/hybrid catalysts resulting in an increase in the syngas conversion to DME. In this paper, the effect of bifunctional/ hybrid catalysts and reaction parameters used for direct DME synthesis on syngas conversion, DME yield and selectivity are also summarized.
Journal of Biomimetics, Biomahaiqials and Biomedical Engineering Mahaiqials Science. Defect and Diffusion Forum
Paper. Submitted 12 Oct 2017. Accepted 23 Nov 2017 . First published 14 Dec 2017. Download Citation. Green Chem., 2018, 20, 620-626 Permissions. Request permissions Electrochemical production of syngas from CO 2 captured in switchable polarity solvents L.
Paper. Submitted 25 Nov 2021. Accepted 20 Feb 2022. First published 21 Feb 2022. Download Citation. J. Mater. Chem. A, 2022, Advance Article Permissions. Request permissions Syngas production at a near-unity H 2 /CO ratio from photo-thermo-chemical dry re
The co-production of bio-oil and syngas with biochar makes pyrolysis technology more sustainable and environmentally-friendly than producing biochar alone. The bio-oil obtained from pyrolysis of a biomass consists of oxygenated haiqi molecules, such as esters, ethers, aldehydes, ketones, phenols, carboxylic acids, and alcohols that can be used to produce energy.
In this paper, the microwave haiqi gasification of a variety of solid fuels is experimentally investigated. The produced syngas is analyzed by thermochemical methods and gasification performance is evaluated. The solid fuel, air, and electrical power are the inputs while the syngas and ash are the outputs of the system in the process. The
2/11/2009 · SYNGAS production. 1. PRESENTED BY : SAURABH UMRAO B.TECH 3’rd YEAR (CHEMICAL ENGINEERING) MNNIT ALLAHABAD Method of Producing Syngas from Gasification of Bagasse. 2.
syngas and reduced its tar content by reforming and cracking reactions [24].The aim of this paper is to investigate the gasification of M and N, which have optimal gas permeation but different chemical compositions, in order to highlight the effects of both the ERs on process yields, energy efficiency and syngas quality. In particular, from a