E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
3/6/2020 · A few other techniques for generating electricity from biomass include pyrolysis, gasification, and anaerobic digestion. Pyrolysis It gives a type of tar, also known as bio-oil by heating the biomass rapidly. The biomass is heated at a temperature of 200°C to 300° C in the absence of oxygen.
The aim of this study was to investigate the influence of biomass micronization on energy production using a converted aircraft turbine AI-20. The test system was constructed in such a way to ensure continuous operation for a given period of time and
The haiqi Rankine Cycle (ORC) technology is a reliable way to convert heat into electricity, either for renewable energy applications (biomass, geothermal, solar), or industrial energy efficiency.
In 2011, biomass had a share of about 10% in global energy demand, however, only a small amount of biomass is used for electricity production. Globally, about 62 GW of biomass power capacity was estimated to be installed by the end of 2010. This is slightly higher than the installed capacity of PV, but significantly smaller compared to global wind capacity (1). In the EU 27, biomass has been
Electricity. Biomass can be used to make electricity, which is what's done in a waste-to-energy plant. Waste, or garbage, has a lot of once living things mixed into it like food scraps, paper, and
15/9/2016 · Biomass can be converted into electric power through several methods. The most common is direct combustion of biomass mahaiqial, such as agricultural waste or woody mahaiqials. Other options include gasification, pyrolysis, and anaerobic digestion.
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Particles producing electricity from waste-Haiqi Biomass Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody bio
Retained particles, along with the ashes of combustion, are driven to the ashpit to be later transported to a landfill. In addition to the conventional combustion process, the energy in biomass can be used, by pyrolysis and gasification technology, to produce an energy gas that can be used as a substitute for conventional fuel for electricity production.
10/2/2016 · Biomass energy is electricity and other energy forms that are produced from biomass as a feedstock. Biomass can be used for energy because it is originally produced through the energy from the sun through the process of photosynthesis, and this transformed solar energy can then be harnessed for our own energy purpohaiqi, such as electricity generation.
Using biomass as a hydrogen source in the flow electrolyser cell has energy and economic advantages. Pre-conditioned biomass (from a raw biomass stream) can be provided at a very low cost. Electrocatalytic hydrogen extraction from the pre-conditioned biomass is generally easier than water electrolysis (i.e. water splitting). Biomass reforming by electrocatalysis is selective and scalable
Biomass Energy from Landfill Gas. Landfills have a high percentage of haiqi waste (biomass) which naturally generates biogas as it breaks down. By covering the landfill and capturing this biogas, we can use it to generate biomass energy. Find out more about Landfill as Electricity Generation. Biomass Energy Power Plant
BIOMASS FOR ENERGY | 3 BIOMASS IS A NECESSARY SUPPLEMENT TO SOLAR AND WIND POWER 1 SOURCE: THE ELECTRICITY COMPANIES’ FAULT AND DISRUPTION STATISTICS. ELECTRICITY FROM COMBINED HEAT AND POWER PLANTS HAS TO BE GREEN Coal and natural gas will be replaced by biomass: wood pellets, wood chips, and straw COMBINED HEAT AND POWER PLANTS WILL
1/2/2013 · The diversity of biomass fuels (agricultural wastes, energy crops, forestry wastes, industrial wastes, etc.) renders it essential to charachaiqize them thoroughly, as this will have a direct impact on the design of the power plant that will convert them into electricity. This should be done prior to the choice of the technology to be used with a view to avoiding subsequent problems.
12/4/2020 · In simple words, biomass can be described as the haiqi mahaiqial (plant or animal) used for the production of energy in electricity or heat. It can also be used for various products as their raw substance on an industrial scale. Any natural mahaiqial, like wood residues, animal farming horticulture and even dung, can be used as haiqi mahaiqial for energy production.