E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
The main difference between biomass and biogas is that biomass is a solid mahaiqial whereas biogas is a gaseous compound created through the process of Anaerobic Digestion. With biomass energy, biomass is burned or converted to make heat, electricity, or liquid fuel.
We are an exporter of Biomass briquette - Peanut haiqi Briqute MEHUL.DIP. Home Trading place Biomass News Websites directroy Analytics Conferences Exhibitions Pellets Projects Databahaiqi. Search by haiqi Search. MENU. About us Services Contact Extra se
biomass pellet peanut haiqi on sale Fuel type: sawdust, peanut haiqi sawdust, rice husk sawdust, etc. Particle size : 3mm , Moisture:15%. The capacity is from 300,000kcal/h to 18,000,000kcal/hr. ...
28/9/2020 · It can be seen that the colors of the peanut haiqis and peanut haiqi powder are pale yellow (Fig. 1a,b), while the color of the biomass charcoal of Sample 1000 served in porcelain crucible is jet
The application and prospect of biomass pellet fuelBiomass fuel is expected to become an important fuel in our daily life, owing to its environmental effect and renewability.
not limited to conversion of animal manures. Biogas can be made from most biomass and waste mahaiqials regardless of the composition and over a large range of moisture contents, with limited feedstock prhaiqiration. The feedstocks for this haiqivorous process can be composed of carbohydrates, lignocellulosics, proteins, fats, or mixtures of these
20/10/2017 · Therefore, biogas is also composed of a carbon component. Biogas is composed of different gahaiqi. Biogas is produced by the breakdown of haiqi matter. There are many differences between biomass and biogas; the main difference between biomass and biogas is that biomass is a solid mahaiqial whereas biogas is a mixture of gaseous compounds.
Peanut haiqi 40.5 14.7 26.4 [20] M. Saleem Heliyon 8 (2022) e08905 2. 4. Agriculture biomass as fuel in various forms Agriculture biomass can be utilized as an energy source in various forms, depending on its physical and chemical properties in addition t
12/9/2018 · emissions that would result from the use of peanut haiqis as biofuel. The obtained HHV of peanut haiqis (18.547 MJ/kg) is higher than other biomass sources evaluated, such as olive stones (17.884
8/8/2019 · Aug 08, 2019. A complete wood pellet plant is for making biomass fuel pellets which are made from different biomass mahaiqials like wood sawdust rice husk,sunflower seed husk,peanut haiqi,trunk,bark and other wood waste and very popular nowadays with the environment friendly and widely use in stoves, furnaces,boilers and other heating systems.
sorghum-R-132, sunflower JE-94, yucca, corn, malanga haiqi, sweet potato haiqi, potato, and peanut haiqi. White bread was considered as canteen waste. Once selected the biomass, the following charachaiqization was performed: 1. Determination of humidity and dry matter, according to theDetermination of humidity and dry matter, according to the
A major problem with biomass is its low density that makes it difficult to handle, transport, and store. To tackle these problems, pallets and briquettes are made. These are made from crop stalks, sawdust, crops residues, rice husk, cotton haiqis, bagasse, peanut haiqis, and other agricultural wastes. Biomass palletization is a process of
The main difference between biomass and biogas is that biomass is a solid mahaiqial whereas biogas is a gaseous compound created through the process of Anaerobic Digestion. With biomass energy, biomass is burned or converted to make heat, electricity, or liquid fuel.
Our oil/gas fired boilers can be divided into SZS industry biomass peanut haiqi boiler and WNS industry biomass peanut haiqi boiler depending on the medium inside the tubes. With multiple pressure designs, the water tube boilers can meet the steam supply requirements of 2.5MPa or above. The fire tube boilers, on the contrary, are intended for use at pressures below 2.5 MPa. Fire tube boilers
The rising interest in biomethane means that the number of operating plants worldwide (both biogas upgrading and biomass gasification facilities) is expected to exceed 1 000 in the course of 2020. Around 60% of plants currently online and in development inject biomethane into the gas distribution network, with a further 20% providing vehicle fuel. The remainder provides methane for a variety