E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Steam boiler installation running on 1500 °C synthesis gahaiqi the from melting of waste mahaiqials Scope Engineering, delivery and installation of steam boiler including special controlled syngas firing system Key benefits Customized burner solution: multiple-stage combustion of syngas Guaranteed overall performance NOx emissions < 70 mg/Nm3
Emissions from syngas combustion in turbines, engines and boilers are discussed in this review. The types of emissions considered include the unburned fuel components and partially oxidized
Mar 19, 2010 · Alternative resources, such as biomass, and municipal and industrial waste are being considered as a source for the production of syngas to replace natural gas as a power turbine fuel. Pyrolysis of biomass produces a syngas composed primarily of CO, CO 2 , CH 4 , and H 2 with a medium-low lower heating value that is strongly dependent on
21/11/2018 · The ammonia industry dominates the global market for syngas (mainly from fossil fuels like coal, natural gas, and oil/residues) . The production of hydrogen for use in refineries, for instance, the processing of hydrogen, and methanol are other major applications. The current market distribution of syngas is shown in Figure 1.
syngas production from glycerol. It was ob-served that gas flow rate had little effect on syngas production while the effects of tem-perature were very evident. When glycerol was heated to 800 ˚C, syngas compositions of up to 93.5% were observed, more than 20% greater than the compositions of syngas at 700 ˚C.
It is the production of this syngas which makes gasification so different from incineration. In the gasification process, the MSW is not a fuel, but a feedstock for a high temperature chemical conversion process. Instead of producing just heat and electricity, as is done in a waste-to-energy plant using incineration, the syngas produced by gasification can be turned into higher value
30/7/2018 · Syngas - Clarke Energy Air. Bed ash. Steam. Biomass. Electrical energy. Exhaust gas. Heat exchanger. Heat consumer. C o m b u s tio n c h a m b e r. Gas boiler. Syngas Schematic Charachaiqistics of syngas reburning in a natural gas firing furnace ... Aug 19, 2016 ... Co-firing of synthesis gas (syngas) produced from biomass/waste ... increasing renewable energy production from existing ...
The feasibility of using the syngas as a supplemental fuel is planned to be demonstrated in a coal-fired boiler in Taiwan. There are several uncertainties, however. The syngas produced from the paper rejects is of low heat content, ranging from 3.99 to 6.24 MJ/kg . In addition, the syngas contains trace amounts of NH 3, HCN, HCl and H 2 S
Syngas can be used as a fuel in a dedicated gas engine. Syngas Engineering, delivery and installation of steam boiler including special controlled syngas firing system. Click to see more. Waste Heat Boiler (Syngas) The process gas waste heat boiler (WHB) is a critical piece of equipment cooling the hot synthesis gas exiting an ATR, a
boiler for syngas. Posted on 2016-12-21 by Jenny Wu. A Study on Performance and Emissions of a 4-stroke IC Engine Operating on Landfill Gas with the Addition of H2, CO and Syngas A thesis submitted in partial . Gas heater – Wikipedia. A gas heater is a
1/7/2008 · It is valuable to consider the environmental impact of this new generation of energy production systems, specifically release of gaseous emissions from combustion of the synthesis gas produced by gasification. Emissions from syngas combustion in turbines, engines and boilers are discussed in this review. The types of emissions considered include the unburned fuel components and partially
Waste heat boiler (Syngas) The process gas waste heat boiler (WHB) is a critical piece of equipment cooling the hot synthesis gas exiting an ATR, a secondary reformer, or an SMR. The heat from the process gas is utilized to generate high pressure and high-quality steam for the process and to drive turbines. Depending on the downstream proceshaiqi and
Syngas from pyrolysis is a combustible gas and can be used for the production of power in many types of equipment, from steam cycles through gas engines and turbines. While the usages in boilers for steam cycles typically do not require extensive gas treatment before the power generation, the gas engines request a higher degree of purification and prhaiqiration. The stability and consistency of
– 20 kg/hr to 300 tonnes/day – Air-blown – haiqipheric pressure – 500-1,000ºC – Fixed bed or fluid bed – Syngas is combusted directly in a boiler to make steam for a steam turbine generator 19 Biomass Gasifiers – Many Types for Different Feedstocks and Applications 20 Fixed Bed Gasifier – Updraft
It is important to differentiate between 'true gasification' (where the syngas Filtration System Protects Boiler Units from Syngas Contaminants. New Filter Units to protect the boiler units from Contaminants in the Syngas. Syngas Power | Why Syngas ? Syngas is an alternative energy & fuel source to pulverised coal, coal seam gas