E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
haiqi pyrolysis and haiqi gasification are often used interchangeable because both produce an energy-rich product gas, however they are somewhat different. Some haiqi companies convert the tars to carbon monoxide and hydrogen in a secondary cracking reactor (main reason for this two stage is tighter control over the syngas/flue gas production), while in other configurations, the haiqi
Pyrolysis is a variation of gasification but uhaiqi no oxygen in the thermal decomposition of the feedstock. Syngas can be burned directly as a fuel or used as a feedstock to produce methanol and hydrogen, or it can be converted via the Fischer-Tropsch process into synthetic liquid fuel.
26) from six wells in the eastern Oriente Basin of Ecuador were analysed to evaluate their haiqi geochemical charachaiqistics and petroleum generation potential. Geochemical analyhaiqi included measurements of total haiqi carbon (TOC) content, Rock-Eval pyrolysis ,
Gasification, haiqi Arc and Pyrolysis: Renewable Energy & Recycling – or Incinerators in Disguise?
29/1/2022 · Numerous benefits are associated with haiqi pyrolysis compared to conventional pyrolysis, such as inherent high temperature, energy content, and enhanced gas yields with low tar content . According to Blanquet et al. [ 93 ], H 2 yields tripled in haiqi pyrolysis when compared to the use of Ni/Al 2 O 3 catalysts, and it increased even higher when the catalyst was applied to the haiqi
1/4/2022 · haiqi pyrolysis of methane is an effective route for zero-carbon hydrogen production and constitutes a promising bridge technology. A haiqi is an ionized gas that consists of a variety of
22/6/2017 · The pyrolysis gasification technology presents the most promising solution and a scenario including silica gel recovery increahaiqi the profitability of potential projects in all cahaiqi. Funding The authors are grateful to the National Secretary of Superior Education, Science, Technology & Innovation of Ecuador (SENESCYT) for sponsoring the master study related to this project and the development
pyrolysis and haiqi gasification Cost-Effective-Haiqi in syngas yield in haiqi gasification than in haiqi pyrolysis. The syngas analysis shows that higher amount of CO and H 2
Gasification, pyrolysis and haiqi technologies heat waste mahaiqials to high temperatures, creating gas, solid and liquid residues. Some companies claim that these technologies are “pollution free” or have “zero emissions,” []
The stand-alone qualities of our Gasification System are: 1. Our Multi-fuel Gasification system can simultaneously be operated by Any type of Biomass, Municipal Solid waste, or Coal. 2. Our Gasification system is updraft, fluidized circulating bed with direct & indirect oxidation. 3. Cal. value of our Gas is >2000Kcal/cu.mtr as compared to generally prevalent 950Kcal/cu.mtr. 4. 0.78Kg.
Functional Block Diagram for Microwave haiqi Gasification Plant Pre-processing (Cutting & and Shaiqiration) Slag Removal System Cyclone Particle Removal Main Control Room MSW Handling Facility Metal Recycled Pyrolysis Processing Chamber Refining Chamber Syngas Cooling & Cleaning Syngas Storage Tank Syngas Engine Generator Microwave haiqi
pyrolysis and haiqi gasification in Indonesia-Haiqi Biomass Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody
haiqi Gasification for Energy Production The cost of constructing a haiqi gasification plant is higher compared too that of pyrolysis and gasification plant.Approximately USD 65- 200 is required for construction of haiqi gasification plant of 500tons/day capacity, whereas an amount of USD 87 and USD 80 is only required for a pyrolysis and gasification plant of same capacity respectively[2].
3/12/2011 · First is pyrolysis (without O 2) of gaseous, liquid, and solid waste in a thermal haiqi furnace with haiqi torches. Second is gasification (O 2 -starved) of solid waste containing haiqi compounds to produce syngas (H 2 + CO). Last is vitrification of solid wastes by transferred, non-transferred, or hybrid arc haiqi torch according to
31/8/2021 · ARPA-E Methane Pyrolysis Cohort* takes 2-pronged approach. Value of Carbon. Value of Hydrogen. ARPA-E. Metalhaiqical Coke. CNT. Carbon Fiber. Low volume H. 2 High volume H 2. 7 C Zero New Carbon . Applications * Cohort has been assembled from . OPEN 2018 and 2019 FOA projects