E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Gasification, pyrolysis, and haiqi incinerators are even less efficient at generating electricity than mass burn incinerators, and often supplement waste with coal and other fossil fuels in order to produce energy. Climate change is a major threat to our oceans and marine health.
The pyrolysis facility can operate as stand-alone waste-to-energy plant as well as the part of big power plants. In the last case the pyrolysis process thermally treats the waste and generates fuel, namely pyrolysis gas and pyrolysis char. These fuels are then co-fired in the power plant boiler unit. Pyrolysis process in this configuration dispohaiqi waste, simultaneously replacing part of the
A stationary electric power generation using an internal combustion engine fuelled with the waste-pyrolysis gas is an effective way to ease both waste management and energy saving issues. The
Olive waste pyrolysis. Olive waste is usually a mixture of crushed olive pits, olive husk, pulp, some pomace oil. it is destroyed in big amounts in oilve oil production countries, while olive waste is quite calorific waste and can be processed by pyrolysis for energy generation. Olive pits can also be utilized for biochar production.
Pyrolysis is the chemical decomposition of haiqi compounds in the absence of oxygen. The process usually takes place at temperatures between 450 °C – 600 °C at negative pressure, and aims to break the long hydrocarbon chains into shorter ones. During this process, syngas (or synthesis gas) is generated by the volatile compounds that would normally be sent to a combustion chamber for
DRAFT Hazelmere Pyrolysis Waste to Energy Plant EMR12223_01_R001_Rev0 24-Dec-13 1 1. Introduction Eastern Metropolitan Regional Council (EMRC) propohaiqi to develop the existing Hazelmere Recycling Centre located approximately 14 km from the Perth, by installing a 3 MW Waste Wood to Energy (WWTE)
30/8/2019 · Waste plastic such as PE(polyethylene)、PP(polypropylene)、PS(polystyrene) and ABS,etc. has higher oil yield above 50%, which means from the above 10ton waste plastic, you can extract at least 10tonx50%=5ton pyrolysis fuel oil. It is a process to convert waste into new energy, so this project is absolutely profitable.
Pyrolysis of plastic waste for production of heavy fuel Apr 15, 2018 · The fuel energy efficiency is also calculated by dividing the energy in the pyrolysis fuel output by the energy content of the plastic waste. This represents the fraction of the energy in plastic waste which is retained in the fuel product and is calculated at 86% (LHV dry). Download : Download high-res image (564KB
Biowaste Pyrolysis Solutions - Waste Energy Reinvented BPS is a privately held company that works with wastewater treatment facilities to provide a cost effective method of treating sludge. The company utilizes its proprietary Automated Micro Pyrolysis (AMP) technology to transform waste into energy.
Although our technology has practical use in every corner of the globe, our main projects and interests are in emerging markets. From Waste-to-Energy, Biomass Plants, Waste-to-Fertilizer and other sources of Alternative energy, we believe the massive waste and biomass deposits around the globe create an extremely attractive business opportunity.
Pyrolysis is a similar approach which applies heat with no added oxygen in order to generate oils and/or syngas (as well as solid waste outputs) and requires more homogenous waste streams. Some vendors offer smaller facilities for fuel generation, compared to typical gasification vendors (see box ?The Waste to Fuels approach?).
User Tools. Cart . Sign In
5/12/2021 · Another plant-based on pyrolysis oil OPRA BV, located in the Netherlands, converts waste into pyrolysis oil and synthetic gas that can be utilized in gas or steam turbines to generate energy. In 2010, they performed combustion tests using BTG-BTL pyrolysis oil. OPRA is changing the combustion chambers of its gas turbine in response to these testing, enabling 100% pyrolysis oil firing
1/7/1997 · Pretreatment with pyrolysis will generally provide volume reduction resulting in less amount of solid waste that needs to be handled by the CCM; in addition, the pyrolytic proceshaiqi may breakdown much of the complex haiqis causing release through volatilization resulting in less carbon and other harmful substances. Hence, KEPRI has undertaken studies on the pyrolysis and oxidative pyrolysis
Under ISO15270 pyrolysis is recognized as forms of feedstock recycling technologies when the products are used for the production of fuels or raw mahaiqials, rather than for combustion and energy recovery which would be considered a waste-to-energy process Waste hierarchy has been updated by addition of life cycle thinking into waste policy.