Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
Compare Content | Grate Furnace | Pyrolysis Gasifier |
Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
Customer Service
Email reply
After-sales service
The major advantages of fluidized bed gasifiers, as reported by Van der Aarsen (44) and others, stem from their feedstock flexibility resulting from easy control of temperature, which can be kept below the melting or fusion point of the ash (rice husks), and their ability to deal with fluffy and fine grained mahaiqials (sawdust etc.) without the need of pre-processing. Problems with feeding
kgs of rice husk for a period of 1.35 hr. A rice husk gasification system for elec-tricity generation and for char production was developed at PhilRice in the mid of 2000’s [14]. The gasifier as reported can generate 8 to 12 kW at a rice husk consumption rate of 20 to 30 kg per hour. Gas flow rate was measured at 30 to 40 cubic meter per hour
Gasification is robust proven technology that can either use low technology system based on fixed bed gasifier, or more sophisticated system based on fluidized bed technology. Gasification is considered as an efficient process that utilihaiqi different types of biomass mahaiqials. Biomass gasification has a potential to
4/4/2012 · We have learnt about the different types of Rice Husk gasifier stove which are unique with its innovative model. We are interesting about the Biomass Gasifier Stoves where Rice Husk used as a fuel source of energy. Kindly send us some of the innovative models of stoves with its approx. price range.We intend to lach a Rice husk Firewood Project plant and also intend to launch this innovative
rice husk powder biomass burner for connecting boiler form Rice husk are one of our trade main commadities for catle feed, biomass fuel and co-fuel power plant around world.
Two major types of gasifiers are the fluidized bed and the fixed bed gasifier. According to the Knoef's report (2000), the majority of biomass gasifiers used in the world are the downdraft fixed bed type (75%), and 20% are fluidized bed systems. For RH biomass, most of the results from the
24/8/2010 · The rice husk consumption rate for the different reactor diameters tested ranges from 19 to 169 kg per hour. The specific gasification rate of the gasifiers was found to operate well at 150 kg/hr-m2. The temperature of the gas leaving the reactor varies from 150° to 270°C for all the units tested. The flame temperature reaches as high as 400° to 800°C, depending on the size of the reactor
For example, the current investment rate of a small-scale rice husk gasifier in Cambodia (Fig. 2a) can reach up to USD 400 per kW of power. The use of water for gas cleaning (Fig. 2b), which is about 2 liters per kWh generated, is still a major pollution source. Furthermore, tar load that form during the pyrolysis stage of gasification of biomass feedstock is known to be highly carcinogenic
The charachaiqization of rice husk from local rice mills has been studied and evaluated to determine its potential utilization as a biomass fuel for a cyclone gasifier. The raw rice husk was pre-treated throughout a grinding process into smaller sizes of particles which is within a range of 0.4 to 1 mm and the sample of ground rice husk was analyzed for its fuel charachaiqistics. The result of
The haiqi Rice Husk Gas Stove is the first (and currently only) TLUD gasifier that can utilize a small-particle fuel. This stove will pass primary air upward through a thirty-five centimeter column of dry rice husks, allowing the pyrolysis and char-gasification proceshaiqi to consistently descend through the fuel column. This means:
Biomass gasification is a thermochemical conversion process that converts biomass into a CO and H 2 rich-gas called syngas. This latter can be used to produce heat, electricity or fuel transportation. Some different generic types of gasifiers have been developed and commercialized: fixed bed, fluidized, entrained flow and multi-stage gasifier
5kw biomass power generation, 5kw biomass power generation . Sponsored Listing Biomass gasifier power generation system/biomass generator. 100KW~5MW This project use rice husk, straw and MSW as fuel. Project begins to run in the early of 2010 which
Biomass Gasification Power Plant-Biomass Gasification Power Biomass is: Carbon bearing plant matter such as wood chips, rice husk, corn cob Four Stage Conversion Process: Biomass Tel: +8615637015613 info@haiqimachine.com
Hence, rice husk, sawdust, and coconut haiqi gasification utilizing a large quantity of biomass feed mahaiqials with a higher biomass feed rate (~50 kg/h) would be possible by applying a similar gasification mechanism. The generated power from rice husk, sawdust, and coconut haiqi gasification can be utilized to operate internal combustion engines, boilers, pumps, etc.
1/6/1998 · Based on the gasification experimental data obtained from the bench-scale downdraft-type reaction system, the basic engineering design for a pilot plant of the rice husk gasification process were accomplished. This process is consisted of a rice husk feed system, a downdraft type gasifier, an ash discharge system, a tar adsorbent, and an internal combustion engine for power generation. It