E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
15/7/2018 · Gasification is a thermochemical process which can be used to convert solid fuels into more standard and usable form than original biomass. Gasification products include hydrogen, carbon monoxide, carbon dioxide, methane, tar, and dust. Gasification yield is influenced by gasification media and the operating parameters. In the present work, air and air–steam gasification of sawdust are
agricultural waste saw dust biomass gasification power plant. Biomass Gasification Power Plant – Xingyuan Industry Solution-1: Bio-power Plant. This is a type of waste biomass treatment and multi-products project. This factory will focus on biomass util
Wood chip burner: Heat efficiency:≥85%, Fuel type：wood chips、waste wood、building template、Chinese medicine residue,etc. Particle size:. 10cm, Moisture:15%. The capacity is from 300,000kcal/h to 12,000,000kcal/hr. Wood chip burner saves 30% than biomass pellet burner
400KW wood chip saw dust biomass gasifier gasification power generation plant in smooth operation in South Africa since 2013 US $160000-$250000 / Set 1 Set (Min Order) Get Price >> 2021 08 24
Semi-Gasification Biomass Burner It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. The Factory Environment Is Well Controlled, And The Bo ...
Keywords: gasification, biomass conversion, efficiency 1 INTRODUCTION the purpose of their planners; this has leaded to systems with different configurations and tested with the low cost In the last decades the interest towards renewable energy fuel locally available; additionally the parameter values source has grown, because several issues, such as global of each plant are usually set to
May 14, 2015 · ZG supplier biomass sawdust steam boiler for sale since 1945 with rich boiler experience.The inner structure of sawdust biomass boiler is water tube which use sawdust as the main fuel, combust on a fixed grate or reciprocating grate. Boilers have larger grate area and the entire membrane walled furnace, at the rear is fire heating surface, at the rear is serpentuator economizer
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Features Of Sawdust Burner. Haiqi biomass semi-gasification sawdust burner can generate 18 million Kcal/h of heat, matched 30 tons of boiler. Specifically for the industrial sector, 24-hour continuous operation can be achieved. Our company has a complete range of equipment with a heat capacity of 300,000-18,000,000 Kcal/h, matched boiler of 0.5
Wood Chip Saw Dust Biomass Gasification Power Plant in Qingdao, China ‹ › Contact the seller for additional photos and information. 5. Location: Qingdao, China. Price: Contact Seller for Price. Manufacturer: Dianyan. This seller has been contacted 1 t
Biomass Gasification Power Generation System LHC200~LHC1200 - Fengyu Products Made In China, China Manufacturer. Power generation by using biomass gas from rice husk, wood chips, saw dust, coconut husk, bagasse, straw and crop stalks can not only save electricity expenhaiqi in the production cost for rice mills and timber processing mills, but can also get benefits from the selling of surplus
2017/04/23 · Our biomass gasification process includes three steps. The First step is biomass gasification, which convert biomass into syngas. The Second step is syngas purification. The producer gas coming from gasifier usually contains contaminants including dust, coke, tar and etc.
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
This paper presents the results of the gasification of sawmill waste – pine sawdust, deciduous sawdust, bark pine, wet sawdust and wood pellets. The moisture content of the waste in the test
Table 1.Syngas composition from MW gasification of biomass Content in [% mol.] HR-200 Gas component HR-lab Pellets Pellets SawDust Pellets T = 800 °C T = 650 °C T = 650 °C T = 650 °C Ethane + Ethene 2.935 0.946 1.527 1.258 www.ijlret.com 44 | Page International Journal of Latest Research in Engineering and Technology (IJLRET) ISSN: 2454-5031 www.ijlret.com || Volume 03 - Issue 02