E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
SMALL-SCALE BIOMASS GASIFICATION IN REGIONAL COMMUNITIES: POSSIBILITIES, ADVANTAGES, PROBLEMS AND IMPACT John Sanderson* and Mark Feltrin Gasification Australia, 4 Finch Street, Notting Hill, VIC. 3168 E: john@gasificationaustralia.com P: (0439) 654 249 (*Corresponding author) ABSTRACT
Small-scale biofuel cogeneration system built around an entrained-flow cyclone gasifier designed to process crushed pellets and sawdust. Multifuel Conversion (MFC) technology: RWE Power AG (Germany) 2: High temperature entrained-flow gasification, optimized to achieve reduction of phosphates to gaseous phosphorous compounds. Focus on recovery
Gasification is to energy produces from solid mahaiqial to convert into gahaiqi such as sawdust, leaves, rice husks and more gahaiqi. In this study, we made a small-scale design of biomass gasification. It will give more several advantages such as simple design, especially for rural area. In this research, we used methods consists of five stages. First is literature study; secondly to design and
A 11.19 kW capacity thermal power consumption laboratory scale updraft gasifier was designed, fabricated and tested in this study with readily available mahaiqials for sawdust and palm kernel haiqi as feedstock. The gasifier volume is designed to hold enough biomass with density of 300 kg m -1 to run for at least 2.2 h without refuelling.
Small scale gasification excels in biomass gasifiers. Typical products are heat and/or power . www.ieabioenergy.com Large scale deployment Great plains synfuel plant 1972 –Decision taken to build a coal gasification flagship 1980 –Construction finally
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Figure 1. In small-scale, pyrolysis oil fuelled diesel power plants, direct com bustion of sawdust in a gas turbine, and the gasification diesel studied in this project are technologies competing with the conventional steam process. Of these alternatives, the gasification diesel is most close to the commercial level.
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
the community is to overcome the highly prices of oil and gas. Therefore, an alternative energy innovation from biomass is needed. Gasification is to energy produces from solid mahaiqial to convert into gahaiqi such as sawdust, leaves, rice husks and more gahaiqi. In this study, we made a small-scale design of biomass gasification.
In this work, two small scale throat-less downdraft gasifiers (gasifier I & gasifier II) are tested on feedstocks of rice husk and sawdust at different setup. The test aims to compare the two
biomass system to convert biomass in the form of sawdust into electricity and heat. The technical objectives were designed to achieve a significant reduction of capital equipment costs, thus enhancing the economics of small-scale biomass heat and power projects using this technology compared with other commercial biomass gasifiers. experimental
CESA requested a market ashaiqisment of small- and medium-scale biomass gasification technologies that use solid biomass to generate heat, power, or combined heat and power (CHP). Solid biomass refers to wood and agricultural resources. 1.1. Goals and Meth
1/9/2017 · Small size biomass yields more producer gas than larger size biomass for particular gasification time. Heat transfer area increahaiqi with particle size reduction, thus enhances volatile released during pyrolysis process . Gasification of small size biomass may have high pressure drop problem as well as high dust content in producer gas.
In this work, two small scale throat-less downdraft gasifiers (Gasifier I & Gasifier II) are run on feedstocks of rice husk and sawdust at different runs set up. The runs aim to compare the two gasifiers in terms of continuous flammability duration of producer gas. The result shows that maximum 32 minutes continuous flammability duration is obtained from set up C (Rice husk gasification with 1
Buy small gasifiers generator by using biomass sawdust wood pellet from Machine Business Opportunities, small gasifiers generator by using biomass sawdust wood pellet specifications: 1.we have 5-200kw gasifier generator, 2.use biomass , save cost, small gasifiers generator