E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
1/3/2021 · The sustainability of biomass for energy The European Academies Science Advisory Council (EASAC) is among the leading voices to claim that using biomass for energy is bad for the climate. But that
29/5/2019 · In 2009 and 2010, two new sets of screw expansion generators (with an installed capacity of 2 MW) have been put into operation, respectively. 38 The total installed capacity has reached 26.18 MW, whereas the original 1000-KW units have been discontinued. 18, 38 This power station has achieved excellent economic benefits in the past few decades of operation and contributed to 50% of Lhasa's
23/9/2014 · In this study, the authors experimentally investigate the performance of the haiqi Rankine cycle (ORC) and screw expander under the influence of supply pressure and pressure ratio over the expander. Three tests were performed with expander pressure ratios of 2.4–3.5, 3.0–4.6, and 3.3–6.1, which cover the over-expansion and under-expansion operating modes. The test results show a
20/9/2020 · In contrast to what the comments suggest, the article does not advocate the expansion of biomass as an energy source. Instead, it argues that already burning biomass fires – used by roughly 40% of today’s global population – could also produce electricity as a by-product, if they are outfitted with thermoelectric modules.
Home » News » Haiqi Biomass Gasifier Factory » Screw Expansion Generator biomass energy plant Waste Gasification Power Plant Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
7/5/2018 · The Kaishan power plant using direct expansion through our Kaishan oil free screw expander generates power expanding steam or gahaiqi. It can also be used as a valve to drop the pressure in steam pipelines or added to a boiler as a thermal plant burning any fuel as coal, gas, diesel, biomass, etc. This
with it. The combustion of biomass produces thermal energy and/or electrical. energy. Biomas s combustion plants that produce electricity from steam turb o-. generators have a con version
Home » News » Waste To Energy » Screw Expansion Generator bio mass energy. capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody ...
Biomass energy is converted into sources of fuel through thermal and chemical proceshaiqi. Even biochemical proceshaiqi are used for conversion of this energy to tangible fuel sources. Provided below is a quick glance of some biomass energy resources, and the proceshaiqi for producing biofuel types, along with the costs incurred in utilization of
The installed existing biomass power pl ant in Karnataka are of the 6. MW range and the design heat ra te of such plants is 4300 k.Cal/kWh. These power plants have specific f uel consumption (rice
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Home » News » Waste To Energy » sustainability biomass gasifier generator products sustainability biomass gasifier generator products The Role of Biowaste: A Multi-Objective Optimization Platform for Sep 1, 2021 Damartzis and Zabaniotou (2011) reviewed and ranked different biomass-to-biofuels gasification designs based on econo
The biomass plant will operate on a 24-hour-a-day and 350-day-a-year basis, with an average consumption of 55 t/h (460,000 t/year) of residual forest biomass to produce steam of high pressure in a boiler, which will then be fed to a condensing turbine to produce electrical energy in the respective generator.
(3) designing a business model for the development of renewable energy based on bamboo forest biomass in rural areas that can guarantee sustainable regional growth. Methods: The study uhaiqi soft
A stationary electric power generation using an internal combustion engine fuelled with the waste-pyrolysis gas is an effective way to ease both waste management and energy saving issues. The