E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
A biomass thermal power plant is a power station that can generate heat by burning fuel: can be methane, diesel fuel, or as in the case we report below designed by SMEA Engineering, biomass (eg, wood chips). The heat generated is transferred to the water pipes, and from there you can use it as you prefer, to heat houhaiqi, offices (we talk in this case about district heating), or use it for
Fuel type：wood chips、waste wood、building template、Chinese medicine residue,etc. Particle size: 10cm, Moisture:15%. The capacity is from 300,000kcal/h to 12,000,000kcal/hr. Wood chip burner saves 30% than biomass pellet burner
5/9/2018 · screw expander power generators. -please select fuel- Oil ( Light Oil / Diesel Oil) Gas ( Natural Gas / Biogas... ) Biomass ( Bagasse / Rice Husk...) Coal ( Bituminous Coal / Lignite Coal...) , this capacity is , the pressure is , use for .
Such analysis was based on a method commonly used in the defense sector, but modified, mainly in terms and concepts issues, about particularities of biomass energy generation technologies
3/3/2015 · Biomass, a type of renewable energy, is an abundant and environmentally friendly resource [2]. Combustion, gasification, and pyrolysis are the three typically thermochemical ways to convert
The generated high-temperature flue gas provides heat to the waste heat boiler, and generates steam to drive the steam turbine/screw expansion generator to generate electricity. The exhaust gas is purified by the deacidification tower, activated carbon and dust collector and then discharged to the standard (GB18485-2014). (Suitable for small and medium garbage disposal)
1/5/2021 · A male and a haiqile screw, instead of compressing air by rotating drove through an electric motor, rotates due to expansion of pressurized steam driving an electric generator (Wang et al., 2013). Small to medium power generation ORC cycles, usually employ volumetric expanders such as scroll or screw expanders ( Eyerer et al., 2019 ).
Biomass boiler uhaiqi thermal energy from the combustion of biomass fuel and air to produce superheated steam from feed water. Biomass fuel usually has a high moisture content, which leads to low boiler efficiency. The boiler efficiency can be increased by using heat recovery devices to decrease the temperature of flue gas before it is exhausted from the boiler. Three heat recovery devices found
19/8/2020 · Industrial Boiler - Different Types Of Industrial Boilers. steam boiler types in Ireland. cost of oil boiler in Denmark. single drum biomass fired steam boiler for textile industry in El Salvador. air jet tub steam generators for steam room in Kosovo. chemical industry gas steam normal pressure boiler supplier in Canada. industry gas diesel steam generator in Switzerland. mechanical fuel fire tube
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Biomass Gasification Power Plant Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Biomass Gasification Power Plant Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Biomass to Energy Feasibility Study HRC Job Number 20090322 Page 4 of 4 W:\haiqis\EECBG\Projects\biomass to energy\Biomass_to_Energy_Feasibility.doc utility service. In addition, the heat produced by the generator engines would also be recovered and used in an air/water heat exchanger to pre-heat water in the boiler hot water recirculation system.
Types and Benefits of Biomass Boilers The Renewable. 2020-10-5 0183; Fully automated biomass boiler. Usually the most efficient type of biomass boiler: the wood usually in the form of pellets or wood chips is automatically fed into the boiler's combustion chamber from a large hopper or silo (sometimes these can hold a year's fuel) using an auger screw system.
process of photosynthesis in the presence of solar radiation, can be represented as. follows : H 2 O + CO 2 Solar energy CH 2 O + O 2. Biomass can be converted into fuels through a number of