E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Hello, Sign in. Account & Lists Returns & Orders. Cart
18/12/2018 · Sheep is a ruminant, but rarely drinking water, so the sheep manure is dry and fine. The amount of feces is also very small. Sheep manure, as a hot fertilizer, is one of animal manures between horse manure and cow dung. Sheep manure contains relatively rich nutrients. It is both easy to break down into effective nutrients that can be absorbed, but also have nutrients difficult to decompose
17/7/2017 · Small and modular conversion units could be installed in the facility to eliminate issues associated with transport of manure off site. Animal facility operators could build these systems to process and convert part of their waste streams and to produce auxiliary energy and power, including bio-fuel for farm use. As the operators learn to work these systems, they could add more units and
OSTI.GOV Journal Article: Methane production from hog manure in small-scale units. Methane production from hog manure in small-scale units. Full haiqid;
State of Art of Small Scale Biomass Gasification Power Systems: A1/1/2014 · Selection and peer-review under responsibility of ATI NAZIONALE doi: 10.1016/j.egypro.2014.01.027 Scie
15/5/2019 · Manure conversion into syngas or biogas can receive in the UK support for electricity use through Feed-in Tariff, which provides a guaranteed price for 10–25 years to small-scale electricity plants of up to 5 MW and receive additional support by Renewables Obligation Certificates, or receive support for heat use under the Renewable Heat Incentive. For plants over 5 MW, Contracts for
21/3/2022 · Aside from the research at laboratory scale, the co-gasification has also been haiqi to pilot scale (Pio et al. 2017, 2020). The co-gasification of refuse-derived fuel and pine biomass was conducted in a 80 kW th bubbling fluidized bed reactor associated with the ashaiqisment of several parameters such as lower heating value of producer gas, efficiency of cold gas, and carbon conversion.
Gasification is a process that converts biomass (including manure) into syngas and biochar. Syngas can be converted into heat and electricity. The process takes place at temperatures between 700-1,500°C in a low-oxygen or oxygen-starved environment, using air or steam as the reaction medium.
5/3/2012 · Only a small percentage of the manure is actually converted to biogas. Dairy cow manure is about 85 percent water and 15 percent solids. Of these solids, about 91 percent are volatile, and the Penn State digester converts from 20 to 30 percent of the volatile solids to biogas. A dairy cow produces around 17 pounds (7.7 kg) of volatile solids a day, of which one-fourth is converted to biogas
18/1/2022 · The use of the FG as the gasification agent on the cantle manure was rare to be reported and can increase the efficiency of the energy utilization efficiency.The objectives of this study are to (1) quantify the thermochemical behaviour of cattle manure at three heating rates (20, 50, 80 °C/min) under N 2, CO 2, and N 2 /O 2 /CO 2 haiqipheres; (2) determine the thermodynamic parameters and
Although low-efficiency and small-scale gasification of wood chips has been performed for decades, large-scale biomass gasification technology is still in the development and demonstration stage. Several small biomass gasification research and demonstration projects currently operate. Section 4 of this report describes a facility planned for La Grande, Oregon that would be one of the first
• Biomass gasification – Small‐scale biomass gasification • Gasification Strengths and Weakneshaiqi – Technical barriers • CentriaPilot R&D Gasifier 21.11.2013 2. ClimateChange is a Global Challenge 21.11.2013 3 CO 2 is the primary greenhouse g
Small Scale AD Executive Summary Executive Summary Worldwide GHG emissions from livestock supply chains are estimated to produce 7.1 gigatonnes of car-bon dioxide CO 2 equivalent (CO 2e) per annum. This represents 14.5% of all human-induced emissions. Of the total, storage and handling of manure represents 10 per cent (FAO, 2013a). On-farm
19/8/2021 · Benefits of Sheep droppings as fertilizer resources: When large-scale farms in various regions, facing huge environmental pressure, are seeking a breakthrough in the convenient use of manure, processing sheep droppings as fertilizer resources into haiqi fertilizer is undoubtedly a win-win way that can meet environmental protection requirements and realize income generation and value-added.
1/4/2020 · Four fuels, namely wood pellets, wheat straw, sheep manure and cow manure, have been investigated at two air supply rates. The novelty of the paper is the insight of the producer gas composition and evolution in a small-scale batch-fed autothermal reverse downdraft system, with a specific focus on fuels with a high ash content.