E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
uniformity within the furnace, thereby reducing heating time, increasing productivity, improving product quality, and lowering heat demand per unit of output. Maximizing heat transfer can create energy savings of up to 25% by shortening melting or heating times for the aluminum and increasing furnace productivity. Uniform heat distribution in
1/2/2021 · Steam gasification of biomass enables the production of a gaseous secondary energy carrier with a calorific value typically in the range of 12–14 MJ/m n 3.The produced gas can be conditioned and thereafter utilized in a variety of proceshaiqi, such as synthesis [] and fermentation [] to produce different products.
Coal Gas Generator Syngas Gasifier for Aluminum Melting Furnace, Find Details about Gas Gasification Generator, Gasification Generator from Coal Gas Generator Syngas Gasifier for Aluminum Melting Furnace - Henan Dianyan New Energy Technology Co., Ltd.
of Boliden or Umicore Isasmelt furnace [3]. In more typical copper pyrometallurgy, the presence of halides is strongly unwanted (however, volatilization of metal chlorides as a method of metal recovery is also considered in the literature [8]). On the other hand, steam gasification of electronic waste was discussed in the literature only for the
Application boiler: Steam boiler, aluminum/ copper melting furnace Heating value: 5 MJ/Nm3 6 Output : Electricity, heat, and char Steam boiler，27 tons/day Aluminum melting furnace，135 tons/day Drying oven，108 tons/day Stainless steel furnace， 270 tons/day Aluminum melting furnace， 216 tons/day 3. Case studies
15/9/2016 · In this study, the isothermal tests for steam gasification of Dezhou (DZ) low-rank coal with molten blast furnace slag (BFS) were performed in a lab-scale continuous gasification system, to investigate the status of gasification and syngas production. The results showed that molten BFS provided the heat needed for gasification reaction to ensure gasification is successful. The carbon
1/3/2022 · Measurements of steam gasification were conducted by a thermovolumetric method under isothermal conditions at an elevated pressure of 1 × 106 Pa and at four temps. ranging from 1073 to 1273 K. On the basis of the obtained results, curves of the formation rate of gasification products were developed and yields of main products (hydrogen and carbon monoxide) were evaluated. The influence of the
Considering high-moisture municipal solid waste (MSW) of China, a steam dried MSW gasification and melting process was proposed, the feasibility was tested, and the mass and energy balance was
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
1/4/2012 · The gasification and melting furnace consists of three main parts: a drying and preheating zone, a thermal decomposition zone and a combustion and melting zone. MSW is gradually dried and preheated in the upper section (the drying and preheating zone). Combustible waste is thermally decomposed in the second zone and syngas is discharged from the top of the gasification and melting furnace. The
The energy content of the gas is sufficient to use in furnace of metal melting, glass melting, cement industries, ceramic industries, mineral industries, etc where process temperature requirement is very high i.e. in the range of 1000-1300oC. Thermal efficiency of the gasifier is 60-70%. AEL has designed updraft gasifier to use the moisture and tar free gas with 99.9% pure gas. Imported coal
Gasification in Aluminum Melting Furnace . Create an excellent brand of global smart energy Waste Gasification Power Plant Waste gasification power plant: capacity
benefit of biomass energy in Aluminum Melting Furnace . Create an excellent brand of global smart energy Waste Gasification Power Plant Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity. View
1/2/2021 · This study investigated its performance in pyrolysis, steam co-gasification, and ash melting. During pyrolysis, derivative thermogravimetry showed shoulder curves indicating higher hemicellulose content compared with timber waste. Steam co-gasification was evaluated using a laboratory-scaled fixed-bed downdraft gasifier. The results showed that blending the substrate with Erianthus at a blend
coal gasification one stage coal gasfier coal gas furnace for aluminium melting industry in vietnam Single Stage Coal Gasifier - sinogasifier The coal gasifiers designed and manufactured by our company use steam and air as the agent for the mixed coal gas production.