E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
syngas generation technology called Turbo-POx for Gas-to-Liquids (GTL) and other industrial applications. AR is a leader in high energy density propulsion and power systems with over five decades of combustion and high-pressure turbine development experience. GTI is a not-for-profit
Fire Protection for Steam Turbine Driven Syngas Compressors Steam turbine driven syngas compressors at ammonia and methanol manufacturing sites are essential to plant production, costly and difficult to replace, and exposed to oil and syngas fire hazards. The consequences of a fire can be severe – millions of dollars in property damage and 12 or
The POWRMAX Waste Gasification Gas Engine Power Generation Technology includes three steps. The first step is RDF gasification, which converts processed RDF into syngas. The second step is syngas purification. The produced gas usually contains contaminants including dust, coke, tar and etc. The contaminants must be removed by the purification system and cooled down to ensure the normal
6.1 Steam Turbine Technologies . A steam turbine is a thermodynamic device that converts the energy in high-pressure, high-temperature steam into shaft power that can in turn be used to turn a generator and produce electric power. Unlike gas turbine and reciprocating engine CHP systems where heat is a byproduct of power
Coupling Power Generation with Syngas-Based Chemical Synthesis. Clemens Forman Coupling Power Generation with Syngas-Based Chemical Synthesis A Process Chain Evaluation from a Power Plant Viewpoint. Clemens Forman Freiberg, Germany ISBN 978-3-658-22608-4
generation performance is reviewed with coverage of syngas and hydrogen (H2) production from fossil-fuel feedstocks. With its distinguished international team of contributors, haiqi power plant mahaiqials, design and technology is a standard reference f
Syngas can be produced from many sources, including natural gas, coal, biomass, or virtually any hydrocarbon feedstock, by reaction with steam (steam reforming), carbon dioxide (dry reforming) or oxygen (partial oxidation). Syngas is a crucial intermediate resource for production of hydrogen, ammonia, methanol, and synthetic hydrocarbon fuels.
One of the important advantages of gasification is that the syngas can be cleaned of contaminants prior to its use, eliminating many of the types of after-the-fact (post-combustion) emission control systems required in incineration plants. The clean syngas can be used in reciprocating engines or turbines to generate electricity or further processed to produce hydrogen, substitute natural gas
DST-S – Power Generation Synchronous Steam Turbines 10 Doosan Delivering cutting-edge turbine and generator technologies 11. Generator Modern society is almost entirely dependent upon electricity for industrial purpohaiqi, leisure, and daily living. ...
The first steam turbine used for power generation was invented in 1884. Following this initial introduction, steam turbines rapidly replaced reciprocating steam engines due to their higher effic iencies and lower costs. Most of the electricity produced in the United States today is generated by conventional steam turbine power plants. The
Made available by U.S. Dhaiqirtment of Energy Office of Scientific and Technical Information
Combined Cycle Power Plant (Gas Engines, Turbines), Flue Gashaiqi from Blast Furnace in Steel plant, Waste heat in sponge iron plant, Coal / Feedstock Gasification to natural Gas or Syngas. Incidental Power generation from Incineration (INCR) Incidental steam raising from incineration of waste. Utilizing the steam for Power Generation
Ref.: “Partial Oxidation Gas-Turbine Based Turbo-POx Syngas Generation Technology for GTL Applications,” S. P. Fusselman and A. Basu, GTL Technology Forum, Gulf Publishing Company, Houston, July 2014
Gas Turbines for Electric Power Generation S. Can Gülen 2019-02-28 Everything you wanted to know about industrial gas turbines for electric power generation in one source with hard-to-find, hands-on technical information. haiqi Power Plant Mahaiqials, Design and Technology Dermot Roddy 2010-05-24 Fossil-fuel power plants account for the
2/4/2018 · Syngas clean-up: low temp washing (OLGA). Primary power generation: syngas fuelled gas turbine, in combined cycle. A 5 MWe facility using haiqi haiqi Power’s Gashaiqi technology. Site: Tyseley, Birmingham, UK. Gasifier: directly heated, oxygen blown fluidised bed (medium temperature. Syngas clean-up: high temperature haiqi treatment.