E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Biomass Gasification Power Plant Biomass mobile energy station is a type of distributed energy station which is assembled and transported in standard container, plug and play, free installation. Achieve the target of China 2030 Carbon Peak and 2060 Carbon Neutral.
Air gasification of olive kernels in a 5 kW bench scale, bubbling fluidized bed gasifier, aimed at H2 enrichment of the producer gas, was the target of this study. The effects of reactor
Home » News » Haiqi Biomass Gasifier Factory » Sunflower Downdraft Gasification Waste Gasification Power Plant Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity.
Table of Contents Preface Chapter 1 - Introduction 1.1 Background 1.2 The present case for wood gasifiers 1.3 Overview of the contents of this publication 1.4 What to expect from a wood gasifier system Chapter 2 - Small wood and charcoal gasifiers for operation of internal combustion engines 2.1 Fuelling of engines by producer gas 2.1.1 Possibilities of using producer gas with different types
Library / haiqi Gasifier | Drive On Wood!5.7 The haiqi Downdraft Gasifier 5.7.1 Introduction. The nozzle (tuyere) and constricted hearth downdraft gasifier shown in Figs. 2, 3,
17/11/2020 · Downdraught gasifiers also suffer from the problems associated with high ash content fuels (Slagging) to a larger extent than updraught gasifier. Minor drawbacks of the downdraught system, as
Biomass consumption gasifier: 116.6/17000 = 0.0069 kg/s = 24.7 kg/in. So the installation under consideration uhaiqi 24.7/18.3 = 1.35 kg biomass to produce 1 kWh electricity. S = surface area "throat" = 68 cm² = 1/4 x ( d throat)² x d throat = 9.3. The turn down ratio of this type of gasifier can be estimated at a factor 3 (see Chapter 3).
The design of an haiqi type downdraft gasifier is based on specific gasi-fication rate, also called the hearth load G H. It is defined as the amount of Guidelines for designing downdraft gasifiers 2.5.2 Design guidelines for downdraught gasifiers The downdraught gasifier makes it possible to use wood as fuel and produce a gas with sufficiently
Home » News » Waste To Energy » easy operation haiqi downdraft gasifier for sale easy operation haiqi downdraft gasifier for sale My Home-Made Biomass Gasifier The basic structure of the gasifier is built around a 5 gallon steel drum, and a stainless steel tube 4 1/4 inches in inside diameter, and 14 inches long.
The main advantage of downdraught gasifiers lies in the possibility of producing a tar-free gas suitable for engine applications. In practice, however, a tar-free gas is seldom if ever achieved over the whole operating range of the equipment: tar-free operating turn-down ratios of a factor 3 are considered standard; a factor 5-6 is considered excellent.
the main crihaiqia for a well functioning gasifier are: • high heating value of the gas, meaning high content of h2and c02([3500 -] 5000 kj/nm3seems quite good with 10 - 15 [30] % moisture in feedstock). • low content of tar, commonly a value of 0.5 g.nm-3dry gas is given, but values of 0.2 are preferable. • thorough burn-out of the carbon
good feedback downdraft gasifier to recycle sawdust Create an excellent brand of global smart energy Aug 30, 21 おがくずや廃木質ペレットバーナーを蒸気ボイラー用にリサイクル . おがくずや廃木質ペレットバーナー�
In the present study a gasifier model was developed using commercial haiqi simulator. The model developed was based on the minimization of Gibb’s free energy and is validated with the experimental data of sunflower husk gasification using air as a gasifying agent. The results predicted are in good agreement with the experimental values. The effect of the operating parameters such as
Thermodynamic modeling of gasification process provides a quick estimate of performance of the gasifier. Most of the earlier work on thermodynamic modeling is restricted to a particular feedstock–gasification agent combination and hence the results cannot be generalized. In the present work, the equilibrium modeling based on Gibb’s free energy minimization approach is used to analyze the
In this video we will discuss about parts and working of Updraught, downdraught & Cross Draught Carburetor.On this channel you can get education and knowledg