E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Generating Unit, just like PC boilers, if: mercury-toxics-emissions | netl.doe.gov Learn more about mercury-toxics-emissions at netl.doe.gov. turbine exhaust gas treatment and 2) syngas treatment. and industrial boilers. GE Syngas Turbines to Debut at haiqi Plant – power-eng.com GE recently shipped its first two syngas turbines to Duke Energy’s integrated gasification combined-cycle
Boiler GHP CHP GV Injection to city gas grid. 8 Syngas as the target product Intensified Gasification for Syngas Chemical Looping Partial Oxidation for biomass to syngas [1] Energy Fuels, 2009, 23, 3804-3809. [2] Ind. Eng. Chem. Res., 2000, 39, 3195-3201
1/1/2005 · The clean syngas from the purification island is then saturated with water prior to be combusted in a gas turbine. The moisture reduces NOx formation in the gas turbine. The chemical energy contained in the syngas is recovered as both power and steam generation via a gas turbine/generator set followed by a waste heat boiler/steam turbine/generator set.
Syngas for Boilers/Kilns by haiqi Systems Corp.. In certain circumstances, pre-existing solid fuel boilers, kilns, dryers and furnaces can be retrofitted to fire renewable syngas in place of fossil fuels. By re-using the existing asset, the overal
Syngas Treatment Unit for Small Scale Gasification - Application. generate heat or electricity, used in the synthesis of liquid transportation fuels, H2 or other chemicals. The liquid product can be used as fuel in boilers, gas turbines or diesel engines (Balat et al. 2009). The following Fig. 1 shows the various products obtained from a
A gasification step converts the feed into a synthesis gas (CO and H2 mixture) , which undergoes the Fischer-Tropsch reaction after H2/CO ratio adjustment and CO2 removal. However synthesis gas
2/4/2018 · Syngas and solid residue treatment plant: Whichever ATT technology is utilised, solids are inevitably produced during the reactor(s), including volatile metals (lead, tin, cadmium, mercury, etc.) and carbon. In gasification-based ATTs, relatively little carbon is produced, but in pyrolysis-based ATTs the level of carbon is significant. The larger particles of solids produced are usually
syngas purification equipment VeloxoTherm™ - Carbon Capture Process System The VeloxoTherm™ process, developed by Inventys, is a direct intensified rapid cycle temperature swing adsorption (i-TSA) process that is largely mahaiqial agnostic.
boiler for syngas weightBoiler 4T H Using Fuel Syngas. Except hot oil boiler, oil gas fired steam boiler and biomass water tube steam boiler is also suitable for textile factories . Home. Products. Biomass Gasifier . Container Distributed Power Plant . Se
Find and compare a variety of syngas purification downloads | energy xprt on the world's largest energy portal. View product and services catalogs, brochures, case studies, company news and more. Contact providers to request information and quotes.
Syngas is used as fuel in internal combustion (IC) engines that are coupled to a of syngas in heat generation equipment, such as steam boilers, cement kilns, Syngas and H2 Co-Production Reference Plant – Illinois #6 Coal.. VIII Btu (ca. 350 Btu/scf) syngas suitable for use as a fuel in boilers, furnaces, or
WoodRoll®, delivering a clean syngas which can be further upgraded to hydrogen for industrial and commercial use. This thesis has the objective of studying the purification of a syngas stream, produced through pyrolysis and subsequent gasification of biomass, in order to power a fuel cell system.
A method for purifying biomass syngas under a positive pressure. The method includes: 1) aerating a pyrolysis gasifier by using an oxidation fan; 2) introducing syngas produced in the pyrolysis gasifier through a water-cooling flue to a water-cooling quench tower; 3) introducing the syngas from the water-cooling quench tower to a waste heat boiler of a water-tube type and a waste heat boiler
Syngas Treatment Unit for Small Scale Gasification - Application to IC Engine Gas Quality Requirement L.C. Laurence† and D. Ashenafi Ecole des Mines de Nantes, GEPEA UMR CNRS 6144 4 rue A. Kastler, BP 20277, 44 307 Nantes Cedex 3, France †Corresponding Author Email:laurence.le-coq@emn.fr (Received July 16, 2010; accepted March 13, 2011)
The hot syngas flows through the center of the waterwall, and high pressure (~1,650 psi) steam is generated inside the tubes from circulating boiler feedwater. At gasifier operating temperatures, heat is transferred primarily by radiation. The syngas exiting the center of the waterwall pashaiqi over the surface of a pool of water located at the bottom of the RSC, before exiting the gasifier/RSC