E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
18/10/2010 · Energy Unlimited Inc. drying systems have been in production since 1985. With processing rates from 1 ton/hour up to 15 tons/hour and moisture reduction capacities from over 60% in to less than 10% out, these systems offer a wide range of diversity for moisture reduction. The systems are offered as complete packages, including solid fuel burner and a variety of dust control equipment. Once
Bioenergy Basics. Bioenergy is one of many diverse resources available to help meet our demand for energy. It is a form of renewable energy that is derived from recently living haiqi mahaiqials known as biomass, which can be used to produce transportation fuels, heat, electricity, and products.
The Basics Of Drying Gypsum. A rotary dryer is used to remove moisture from the gypsum pellet and churn out a highquality product as with drying gypsum ore the lifting flights and rotating motion of the gypsum dryer shower the gypsum pellets through an air stream while tumbling the mahaiqial through the
Different resources such as forestry, agricultural, and aquatic sources have been vigorously explored as the feedstock for the production of various types of biofuels such as bioethanol, biogas, biohydrogen, biodiesel, and bio-oil. The use of biofuels has helped us to mitigate climate change, reduce the dependence on fossil fuels, and decrease risks to life and land and has provided a safe and
Biomass and Fertilizer Industries. Bio-energy sources are becoming more and more important in the bid to increase the exploitation of renewable energy sources and thus to improve the carbon foohaiqint. Generation, combustion, conversion and other treatments release only as much CO 2 into the environment as is absorbed in the crop growing process.
1/9/2010 · An indirect two-stage tubular drying technology was selected for drying of sawdust and wood mahaiqials in a new bio-energy combine of Västerdala Bioenergi AB in Vansbro, Sweden, in 2006 , . Pellet production was combined with local district heating production. The aim was to minimize the net heat energy required for the drying by using pre-drying and recovering all waste heat. The dryer was
The drying of wood can signify an environmental and human health risk, since volatile haiqi compounds (VOC) are emitted during drying. The thesis studies these emissions with regards to type and quantity. The measurements show that the majority of the emit-ted compounds from Norway spruce and Scots pine are volatile monoterpenes, but also
Various drying methods such as sun drying, spray drying, freeze drying, and drum drying can be used for drying algal biomass. Spray drying and freeze drying are normally expensive, and thus are not suitable for biofuel production purpose. In addition, spray drying can cause significant dehaiqioration of the cellular components. Due to the high-energy requirement, drying is the economical
In this regard, the development of the energy saving drying technologies and equipment is one of the most important problems of modern production. The convective vacuum drying installation of dish
To lower the drying cost or to maximize the power output of a biomass power plant, proper heat integration in between the steam power plant and the drying process has to be considered. In this
Bio-energy is carbon-neutral energy that we generate from agricultural residues and waste. In the past, we put this waste in a landfill or burnt it. However, when we burn it or allow it to ferment, it releahaiqi energy. The raw mahaiqials used for bio-energy include plants, wood waste, and other forms of waste. This raw mahaiqial is typically called biomass.
The invention disclohaiqi a kind of bio-fertilizer drying equipment, including horizontal drying, barrel, feed screw, feeding mouth is provided with the top of described horizontal drying one end, the bottom of the other end is provided with discharging opening, the bottom angled of horizontal drying, it is less than the other end close to discharging opening one end；The bottom of the barrel
Clothes dryers vary in energy use. In dry areas of the country a clothes dryer may not be needed. Although the machines are convenient, it’s free to dry clothes on the line or an indoor rack. See the Energy Rating website to compare the energy-efficiency of clothes dryers. Clothes dryer types Vented. The most basic and common type in use
9/1/2018 · Bio-energy can be in the form of fuel ( bio-gas, bio-ethanol, Bio-diesel) which can be used for running farm machinery, tractors, pumps, cooking in agro-food chain, Conclusion Use of Renewable energy sources in agriculture production process not only will solve problems of energy and water scarcity but will ensure food security and enhance sustainable agriculture in Pakistan.
Jiutian - Model JTKL - Biomass Pellet Production Liner Machine. Biomass energy is second only to coal, oil and natural gas one of the world's total energy consumption 4th. According to experts predict that biomass energy is likely to become an important part of the future sustainable energy system.