E-MAIL: info@haiqimachine.com
TEL: 8615637015613
Raw materials: rice husk, straw, herb, film, coconut shell
Advantages: fixed carbon, reproducibile, high volatile, low SO2 emmission, zero CO2 emmision
Raw materials: rice husk, straw, herb, film, coconut shell
Main energy: biomass black carbon, biomass wood vinegar
Biomass gasification power plant: capacity from 200kw to 3000kw, 1kg woody biomass generate 1kw electricity, 1kw woody biomass produce 2-3m3/h syngas, syngas heat value 1100-1500kcal/m3.
Applicable raw materials: a wide range of raw materials, such as straw, wood chips, rice husk, palm shell, bagasse and other agricultural and forestry wastes
particle size: 30-50mm, water content: less than 20%
| Comparison of Grate Furnace Incineration Treatment Technology and Pyrolysis Gasification Treatment Technology | ||
| Compare Content | Grate Furnace | Pyrolysis Gasifier |
| Incineration Mechanism | The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General | Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is Advanced. |
| Furnace Structure And Grate Material | The Structure Is Complex And The Shape Is Large; The Grate Works Under High Temperature, And The Requirements For The Grate Material Are High | The Structure Is Relatively Simple And Compact; The Grate Works In A Low Temperature State, And The Requirements For The Grate Material Are Low |
| Types Of Garbage | Dispose Of Domestic Waste | It Can Process Domestic Waste, Industrial Waste, And Hazardous Waste With High Calorific Value (Including Medical Waste) |
| Area (300t/D) | 40-50 Acres Higher | 30-40 Acres Lower |
| Operating Cost Fly Ash Emissions | Fly Ash Discharges A Lot, Accounting For About 5% Of The Total Garbage | Fly Ash Emission Is Low, Accounting For About 1% Of The Total Garbage, Which Is Environmentally Friendly |
| Acidic Substance And Dust Emission | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively High; The Dust Emission Concentration Is 6000~8000mg/Nm3 | The Original Value Of Acidic Substances Such As So2 And Nox Is Relatively Low: The Dust Emission Concentration Is ≤3000mg/Nm3 |
| Plant Environment | It Is Difficult To Control The Environment In The Plant Area. The Incinerator Workshop Has A Certain Amount Of Bottom Ash And Leachate, Noise, And Odor Pollution. | The Factory Environment Is Well Controlled, And The Bottom Ash, Noise, And Odor Pollution In The Workshop Are Low |
1
60s Online
Customer Service
2
Within 24 hours
Email reply
3
Any time
After-sales service
Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity. Views More Waste Gasifier Waste Gasifier: single furnace treatment capacity up to 50 ton/day, it can treat household waste, industrial waste
Gasification of biomass in a reactor with help of a fluidized bed. The TORBED Reactor by Torftech can convert biomass like wood chips and other agricultural waste into syngas, which can be used to fuel engines or to produce energy and heat. Almost any type of wood can be used such as residue wood, wood from old pallets or fruit boxes, veneer or
The Garbage Is Directly Burned, The Combustion Temperature Is 800~1000°C, The Incineration Mechanism Is General: Using Two-Stage Treatment, The Garbage Is Now Pyrolyzed And Gasified, And Then Small-Molecule Combustible Gas Is Burned. The Combustion Temperature Is 850~1100℃. The Incineration Mechanism Is haiqi. Furnace Structure And Grate
Basic Principle Of Wood Chip Burner:Feeding feedstock into the furnace by even feeding，high temperature pyrolysis suspension semi-gasification combustion，then transfer the heat to the energy-using equipment. Using the principle of radiant heat and convection heat，three-stage air increasing to make wood chip fully burned in the furnace, more than 85% of the heat is transferred to energy
A Novel Woodchip-Gasification Process for Clean Syngas Feeding of Dual-Fuel Diesel Gensets Ferruccio Pittaluga University of Genoa, & president, Tecnoforest Ltd. Italy modality, except for the pressure (now Abstract S tarting from 2011, the innovative SME Tecnoforest Ltd. (formerly an academic spin-off of the University of Genoa) has
SMALL SCALE GASIFICATION CHP (BIOGAS)There are several companies who have developed wood chip or pellet micro-biomass generators for small commercial buildings and they are making some headway in the UK due to the favourable Biogas RHI tariff, 7.6p/kWh with no tariff 2 reduction, compared to 5.5p/kWh up to a maximum 1314 full load hrs for Biomass.
25/8/2021 · Co-gasification of high-moisture biomass with waste mahaiqials has also been carried out. For example, Kaewluan and Pipatmanomai [11] studied the co-gasification of rubber woodchip with around 30% Biomass Engineering has installed and commissioned an 85
Gasification of high moisture rubber woodchip with rubber waste 1/3/2011 · Since the co-gasification of high moisture woodchip with rubber waste was proposed as an alternative to the prhaiqiration of dried wood chip prior to gasification, it is useful to compare the gasification performance and products of the two cahaiqi. (PDF) Gasification of high moisture rubber woodchip with rubber This study
1/8/2020 · Gasification waste from Glyricidia shaiqium woodchip (GGSW) were obtained from a commercial gasification plant in Sri Lanka. All chemicals used in this study were of analytical grade supplied from Sigma Aldrich. Details on BG 4 was given in Table 1:
Woodchip energy from waste plant . Create an excellent brand of global smart energy Waste Gasification Power Plant Waste gasification power plant: capacity from 1000kw to 6000kw, modular design, several modular for big capacity. Views More Waste Gasifier
The results showed that higher reaction temperatures were observed in mixed fuel compared to woodchip experiments. In addition, carbon monoxide, hydrogen, and methane concentrations were increased
leaving the gasification chamber is just as stable (Fig. 2). High temperature and low Table 1 Composition (dry-basis, tar-free, mass fractions) of biomass syngahaiqi produced in the fixed-bed gasification from wood pellets [23], waste wood chips [5, 22] and turkey feathers [4] Wood Wood Wood Wood Turkey Turkey pellets pellets chips chips feathers
wastes, because syngas productio n from gasification of wood chips waste has . highest carbon mono xide and hydrogen due to high pe rc entage of carbo n and . hydrogen in wood chips bio mass (as
Gasification systems are typically relatively small-scale, with a ratio of heat to electrical output usually in the region of 2:1. It is extremely important that combustion of the biomass fuel produces clean gas for the engine, so this type of biomass CHP will normally
The gasification of wood waste with a moisture content level of 9-11% only resulted in a larger share of combustible components in the gas generator. In the case of the pellets, the syngas